Numerical study and validation for two-phase flow of oil and gas in aero-engine bearing cavity

LÜ Ya-guo; ZHANG Mei-hua; LIU Zhen-xia; HU Jian-ping

doi:10.13224/j.cnki.jasp.2014.11.029

Chinese

您当前的位置：

首页 >

文章列表页 >

Numerical study and validation for two-phase flow of oil and gas in aero-engine bearing cavity

更新时间：2026-07-07

- Numerical study and validation for two-phase flow of oil and gas in aero-engine bearing cavity
- Vol. 29, Issue 11, Pages: 2751-2757(2014)
- 作者机构：
  
  西北工业大学动力与能源学院,西安,710072
- 作者简介：
- 基金信息：
- DOI：10.13224/j.cnki.jasp.2014.11.029
  CLC：
- Published：2014
- 稿件说明：
移动端阅览
吕亚国, 张美华, 刘振侠, 胡剑平. 航空发动机轴承腔油气两相流流动数值研究及验证[J]. 航空动力学报, 2014, 29(11): 2751-2757.

doi: 10.13224/j.cnki.jasp.2014.11.029
吕亚国, 张美华, 刘振侠, 胡剑平. 航空发动机轴承腔油气两相流流动数值研究及验证[J]. 航空动力学报, 2014, 29(11): 2751-2757. DOI： 10.13224/j.cnki.jasp.2014.11.029.

doi: 10.13224/j.cnki.jasp.2014.11.029 DOI：

摘要

为检验传统的单向耦合模型是否适用于轴承腔油气两相流流场计算

建立了双向耦合模型.对比分析不同转速喷油后

两种模型腔内空气速度和湍动能的分布.并将双向耦合模型计算的数据与文献中实验数据对比.结果表明:喷油后空气速度分布总体变化规律与单相空气流动相似

但各点处空气速度均明显下降

平均空气速度在转速为8000r/min时变化最快;油滴的运动与蒸发对空气速度和湍动能影响较大

尤其是腔室主流区域空气速度由于油滴的耦合作用将会下降10%~15%

所以油滴对空气场的作用不能忽略.

Abstract

In order to test whether the traditional one-way coupling model was suitable for flowfield calculation of two-phase flow of oil and gas in bearing cavity

two-way coupling model was established. The distributions of air velocity and turbulence kinetic energy in two model cavity after injecting oil with different rotation speeds

were comparative investigated. The data calculated by two-way coupling model were compared with the experiment data in the reference. Some important conclusions were found: in the two-way coupling model

the change law of air velocity distribution after injecting oil is similar with the one-way air flow. However

air velocity reduces markedly at every point and the difference of average air velocity is the maximum in the case of the rotation speed of 8000r/min between these two models; the influence of droplet motion and evaporation on air velocity and turbulence kinetic energy is significant

especially the air velocity which will drop 10%-15% due to the coupling effect of the droplets in mainstream chamber

indicating influence of droplets on the air field cannot be ignored.

关键词

Keywords

references

Views

819

下载量

CSCD

Alert me when the article has been cited

提交

Tools

Publicity Resources

Development path and future trend of carrier-based advanced trainer engine

Thermal protection effectiveness of thermal barrier coatings in turbine blade applications

Aero-engine cycle design approach for multiple operating conditions performance reliability

Relationship between rotor/vanes blade number andnodal diameter number of bladed-disk coupling vibration

ptimum design of rotor structure layout and its mechanical properties

Related Author

PENG Yunlong

WU Xiong

DING Ting

ZHU Jianqin

ZHAO Chaofan

QIU Lu

曹大录

白广忱

Related Institution

National Key Laboratory of Science and Technology on Aero-Engine Aero-Thermodynamics,School of Energy and Power Engineering,Beijing University of Aeronautics and Astronautics

北京航空航天大学能源与动力工程学院

中国航天科技集团有限公司中国空间技术研究院北京卫星制造厂

中国航空发动机集团有限公司中国航空发动机研究院

中国航空发动机集团有限公司沈阳发动机研究所

AI问答

Postal code：100079
Tel：（010）53879206 Email：tmw@bjxintong.com.cn
Technical support is provided by Beijing Founder electronics co., LTD 京ICP备09082226号-64 京公网安备11010602201714号
It is recommended to read the content of this site in Chrome&IE9+. Please switch to extreme mode in browser 360.
Cookies We use cookies to help provide and enhance our service and tailor content. By continuing, you agree to the use of cookies.

⁰