Experiment of wearing characteristics and its effect on leakage of finger seal

杜春华; 吉洪湖; 胡娅萍; 罗健; 马丹; 汤丽萍; 廖凯

doi:10.13224/j.cnki.jasp.2017.01.008

Chinese

您当前的位置：

首页 >

文章列表页 >

Experiment of wearing characteristics and its effect on leakage of finger seal

更新时间：2026-07-07

- Experiment of wearing characteristics and its effect on leakage of finger seal
- Vol. 32, Issue 1, Pages: 53-59(2017)
- 作者机构：
  
  1. 南京航空航天大学能源与动力学院,南京,210016
  2. 中国航空发动机集团有限公司商用航空发动机有限责任公司,上海,200241
- 作者简介：
- 基金信息：
- DOI：10.13224/j.cnki.jasp.2017.01.008
  CLC：
- Published：2017
- 稿件说明：
移动端阅览
杜春华, 吉洪湖, 胡娅萍, 罗健, 马丹, 汤丽萍, 廖凯. 指尖封严磨损特性及其对泄漏影响的试验[J]. 航空动力学报, 2017, 32(1): 53-59.

doi: 10.13224/j.cnki.jasp.2017.01.008
杜春华, 吉洪湖, 胡娅萍, 罗健, 马丹, 汤丽萍, 廖凯. 指尖封严磨损特性及其对泄漏影响的试验[J]. 航空动力学报, 2017, 32(1): 53-59. DOI： 10.13224/j.cnki.jasp.2017.01.008.

doi: 10.13224/j.cnki.jasp.2017.01.008 DOI：

摘要

对间隙、过渡、过盈3种配合的指尖封严的磨损特性及其对泄漏的影响进行了试验研究

分析了不同配合状态下封严件与转子的磨损现象、磨损长度以及封严泄漏系数的分布.试验结果表明:封严磨损随封严与转子相对滑动距离增大而增加；间隙配合状态下

封严出现局部磨损

磨损及其对泄漏的影响主要发生试验初始阶段；过盈配合时

封严件整体均出现磨损

且磨损发生在整个试验阶段

磨损对泄漏的影响在初始阶段较大、之后逐渐减小；封严的间隙越小(过盈量越大)

磨损对泄漏影响越大.

Abstract

Wearing characteristics of rotor and its effect on leakage of finger seals under three different kinds of fit

namely clearance fit

transition fit and interference fit

were experimentally investigated. The wearing of the rotor

wearing length of seal and distribution of leakage coefficient were analyzed. The results show that the wearing is severer when the sliding distance between the seals and the rotor increases. For finger seal with clearance fit

the seal is partially worn and the wear and its effect on the leakage mainly occur at the beginning of the experiment. For finger seal with interference fit

the whole seal is worn and the wear occurs throughout the experiment. The effect of wearing on the leakage is notable at the beginning and then is gradually decreased. The effect of wearing on leakage is greater when the clearance is smaller or the interference is larger.

关键词

Keywords

references

Views

466

下载量

CSCD

Alert me when the article has been cited

提交

Tools

Publicity Resources

Experiment on axis locus of rotor and leakage characteristics of finger seal

Influences of pressure ratio and Reynolds number on flow characteristics of labyrinth seal in compressor stator well

Effect of tip clearance leakage on performance of centimetre-level high subsonic micro axial flow turbine

Orthogonal experiment of effect of fin geometrical parameters on leakage of straight-through labyrinth seals

Numerical Analysis of Heating Boundary Effect on the Characteristics of Rotational Sealing Labyrinth

Related Author

LIAO Kai

TANG Li-ping

MA Dan

LUO Jian

HU Ya-ping

JI Hong-hu

DU Chun-hua

ZHENG Hai-liang

Related Institution

College of Energy and Power Engineer, Nanjing University of Aeronautics and Astronautics

Commercial Aircraft Engine Company Limited, Aero Engine(Group) Corporation of China

School of Power and Energy,Northwestern Polytechnical University

Shenyang Engine Design and Research Institute, Aviation Industry Corporation of China

Department of Aviation Mechanical Engineering, Qingdao Branch of Naval Aviation Engineering Institute

AI问答

Postal code：100079
Tel：（010）53879206 Email：tmw@bjxintong.com.cn
Technical support is provided by Beijing Founder electronics co., LTD 京ICP备09082226号-64 京公网安备11010602201714号
It is recommended to read the content of this site in Chrome&IE9+. Please switch to extreme mode in browser 360.
Cookies We use cookies to help provide and enhance our service and tailor content. By continuing, you agree to the use of cookies.

⁰