Rolling bearing collaborative fault diagnosis technology for casing vibration signal

林桐; 陈果; 滕春禹; 王云; 欧阳文理; 肖圣迪

doi:10.13224/j.cnki.jasp.2018.10.009

Chinese

您当前的位置：

首页 >

文章列表页 >

Rolling bearing collaborative fault diagnosis technology for casing vibration signal

更新时间：2026-07-07

- Rolling bearing collaborative fault diagnosis technology for casing vibration signal
- Vol. 33, Issue 10, Pages: 2376-2384(2018)
- 作者机构：
  
  1. 南京航空航天大学民航学院,南京,211106
  2. 中国航空工业集团有限公司中国航空综合技术研究所,北京,100028
- 作者简介：
- 基金信息：
- DOI：10.13224/j.cnki.jasp.2018.10.009
  CLC：
- Published：2018
- 稿件说明：
移动端阅览
林桐, 陈果, 滕春禹, 王云, 欧阳文理, 肖圣迪. 基于机匣振动信号的滚动轴承故障协同诊断技术[J]. 航空动力学报, 2018, 33(10): 2376-2384.

doi: 10.13224/j.cnki.jasp.2018.10.009
林桐, 陈果, 滕春禹, 王云, 欧阳文理, 肖圣迪. 基于机匣振动信号的滚动轴承故障协同诊断技术[J]. 航空动力学报, 2018, 33(10): 2376-2384. DOI： 10.13224/j.cnki.jasp.2018.10.009.

doi: 10.13224/j.cnki.jasp.2018.10.009 DOI：

摘要

针对基于机匣测点信号的航空发动机滚动轴承故障诊断问题

提出了一种滚动轴承故障的协同诊断技术。通过最小熵解卷积消除信号传递路径的影响以增强信号中的冲击性成分；通过小波变换提取共振频带；通过自相关分析抑制频带信号中的非周期性成分并进一步提升信噪比。依托带机匣的转子试验器分别对人工故障轴承和真实故障轴承进行了两组试验

试验结果表明:相比于其他典型方法

采用所提协同诊断法得到的包络谱中故障特征频率对应的谱峰更加清晰、明显。

Abstract

A cooperative diagnosis technique for rolling bearing faults was proposed for aero-engine rolling bearing fault diagnosis based on casing measuring point signal. Firstly

the minimum entropy deconvolution was used to eliminate the influence of the signal transmission path and enhance the impulsive component in the signal.Then

the resonance band was extracted by applying wavelet transform. Finally

the non-periodic signal components in the resonance band were suppressed by using autocorrelation analysis while the signal-to-noise ratio was further improved. Two bearing tests were carried out respectively on the artificial fault bearing and the real fault bearing on the rotor tester with casing. Test results showed that compared with other typical methods

the spectrum peaks corresponding to the fault characteristic frequencies in the envelope spectrum obtained by the proposed cooperative diagnosis method were more clear and obvious.

关键词

Keywords

references

Views

671

下载量

CSCD

Alert me when the article has been cited

提交

Tools

Publicity Resources

Unknown fault diagnosis of rolling bearing based on improved GWO⁃LightGBM

Position rule of turboshaft engine surge based on bench test

Rolling bearing reliability evaluation method based on LTSA fusion dimensionality reduction method

Convolutional neural network diagnosis method of rolling bearing fault based on casing signal

Application of adaptive tunable Qfactor wavelet transform on incipient fault diagnosis of bearing

Related Author

Qinqin CHAI

Shudi CHEN

Wu WANG

Jie HUANG

Siqi YAN

Benwei LI

Yonghua WANG

Yun ZHANG

Related Institution

College of Electrical Engineering and Automation， Fuzhou University

Aeronautical Foundation Institute，Naval Aviation University

Unit ，People's Liberation Army

华北电力大学能源动力与机械工程学院

北京航空工程技术研究中心

AI问答

Postal code：100079
Tel：（010）53879206 Email：tmw@bjxintong.com.cn
Technical support is provided by Beijing Founder electronics co., LTD 京ICP备09082226号-64 京公网安备11010602201714号
It is recommended to read the content of this site in Chrome&IE9+. Please switch to extreme mode in browser 360.
Cookies We use cookies to help provide and enhance our service and tailor content. By continuing, you agree to the use of cookies.

⁰