Numerical simulation of internal flow field in gas generator of fire extinguishing bomb

Yunfeng LI; Kangqing DENG; Ruihua LU; Peiwen QIN; Chunliang GUO; Lifan YAN; Changlong HUANG

doi:10.13224/j.cnki.jasp.20200385

Chinese

您当前的位置：

首页 >

文章列表页 >

Numerical simulation of internal flow field in gas generator of fire extinguishing bomb

Combustion, Heat and Mass Transfer | 更新时间：2025-04-07

- Numerical simulation of internal flow field in gas generator of fire extinguishing bomb
- Journal of Aerospace Power Vol. 36, Issue 9, Pages: 1942-1950(2021)
- 作者机构：
  
  1.中国航天科技集团有限公司湖北航天化学技术研究所航天化学动力技术重点实验室，湖北襄阳 441003
  2.中国航天科技集团有限公司湖北航天化学技术研究所，湖北襄阳 441003
- 作者简介：
- 基金信息：
- DOI：10.13224/j.cnki.jasp.20200385
  CLC：
- 稿件说明：
移动端阅览
Yunfeng LI, Kangqing DENG, Ruihua LU, et al. Numerical simulation of internal flow field in gas generator of fire extinguishing bomb[J]. Journal of Aerospace Power, 2021, 36(9): 1942-1950.
DOI：

Yunfeng LI, Kangqing DENG, Ruihua LU, et al. Numerical simulation of internal flow field in gas generator of fire extinguishing bomb[J]. Journal of Aerospace Power, 2021, 36(9): 1942-1950. DOI： 10.13224/j.cnki.jasp.20200385.

摘要

为了提高灭火弹灭火性能，优化灭火弹结构设计，利用Fluent对灭火弹气体发生器内流场进行仿真计算，通过改变气体发生器开孔情况及发生剂参数调整弹内流场分布。计算结果显示：当首孔距离等于15倍气体发生器排气孔孔径时，灭火弹壳体近壁面存在5个大小相近且数值较高的压强峰，压力分布最利于灭火弹壳体预制孔槽破裂；灭火弹内气体发生器上排气孔对称性越强，发生器内压力分布越均匀。经过试验验证，仿真所得压力⁃时间曲线与试验测得数据吻合良好，说明该模型适用于灭火弹内流场仿真。

Abstract

In order to improve the fire⁃fighting performance and optimize the structure design of fire extinguishing bombs，Fluent was used to simulate the flow field in the gas generator of fire extinguishing bombs，and the flow field distribution in the bomb was adjusted by changing the opening of the gas generator and the parameters of the propellant.The calculation results showed that when the first hole distance was equal to 15 times the gas generator exhaust hole diameter，there were 5 pressure peaks of similar size and higher value on the near wall surface of the fire extinguishing bomb shell，and the pressure distribution was most conducive to the rupture of the prefabricated hole slot of the fire extinguishing bomb shell；the stronger symmetry of the exhaust holes on the gas generator in the fire extinguishing bomb indicated more uniform pressure distribution in the generator.The experimental verification showed that the pressure⁃time curve obtained by the simulation was in good agreement with the measured data，indicating that the model is suitable for simulation of the internal flow field of the fire extinguishing bomb.

关键词

Keywords

references

刘耀鹏 , 王克印 , 黄勇，等 . 灭火弹爆炸抛撒效应数值模拟与分析 [J]. 陕西理工学院学报（自然科学版） , 2013 , 29 （ 1 ）: 36 ⁃ 41 .

LIU Yaopeng , WANG Keyin , HUANG Yong , et al . Numerical simulation and analysis of the effect of fire extinguishing bomb explosion [J]. Journal of Shaanxi University of Technology（Natural Science Edition） . 2013 , 29 （ 1 ）: 36 ⁃ 41 . （in Chinese）

牛兴林 , 张春阳 , 孟春祥 . 迫击炮森林灭火弹适用性及药剂分散技术 [J]. 消防科学与技术 , 2012 , 31 （ 2 ）: 177 ⁃ 179 .

NIU Xinglin , ZHANG Chunyang , MENG Chunxiang . Applicability of mortar forest fire extinguishing bombs and agent dispersion technology [J]. Fire Science and Technology , 2012 , 31 （ 2 ）: 177 ⁃ 179 . （in Chinese）

吴长龙 . 森林灭火航弹二元中心爆管研究 [D]. 哈尔滨：哈尔滨工程大学 , 2016 .

WU Changlong . Research on two explosive tube in aerial bomb for forest fire fighting [D]. Harbin : Harbin Engineering University , 2016 . （in Chinese）

赵浩合 , 武建德 , 王紫民 . 一种新型迫击炮灭火弹的外弹道仿真研究 [J]. 消防科学与技术 , 2016 , 35 （ 4 ）: 546 ⁃ 548 .

ZHAO Haohe , WU Jiande , WANG Zimin . Study on the exterior ballistic simulation of a new type of mortar fire extinguisher [J]. Fire Science and Technology , 2016 , 35 （ 4 ）: 546 ⁃ 548 . （in Chinese）

王紫民 , 武建德 . 一种新型森林灭火弹的仿真设计 [J]. 消防科学与技术 , 2015 , 34 （ 5 ）: 623 ⁃ 625 .

WANG Zimin , WU Jiande . Simulation design of a new type of forest fire extinguishing bomb [J]. Fire Science and Technology , 2015 , 34 （ 5 ）: 623 ⁃ 625 . （in Chinese）

陈吉潮 , 王克印 , 刘耀鹏 . 基于MATLAB的某一森林灭火弹外弹道仿真与运用 [J]. 陕西理工学院学报（自然科学版） , 2012 , 28 （ 1 ）: 53 ⁃ 58 .

CHEN Jichao , WANG Keyin , LIU Yaopeng . Simulation and application of the exterior ballistic of a forest fire fighting bomb based on MATLAB [J]. Journal of Shaanxi University of Technology （Natural Science Edition） , 2012 , 28 （ 1 ）: 53 ⁃ 58 . （in Chinese）

韩宝成 , 雷红飞 , 徐豫新，等 . 液体灭火弹动态抛撒区域工程计算方法 [J]. 含能材料 , 2011 , 19 （ 3 ）: 310 ⁃ 314 .

HAN Baocheng , LEI Hongfei , XU Yuxin , et al . Computational model of dynamic dispersed area of liquid fire⁃extinguishing ammunition [J]. Chinese Journal of Energetic Materials , 2011 , 19 （ 3 ）: 310 ⁃ 314 . （in Chinese）

陈玉昆 , 王克印 , 黄海英，等 . 中心装药灭火弹结构与爆轰抛撒关系分析 [J]. 消防科学与技术 , 2014 , 33 （ 8 ）: 946 ⁃ 948 .

CHEN Yunkun , WANG Keyin , HUANG Haiying , et al . Analysis of the relationship between the structure of the central charge fire extinguishing bomb and the detonation and dispersal [J]. Fire Science and Technology , 2014 , 33 （ 8 ）: 946 ⁃ 948 . （in Chinese）

朱聪 , 梁增友 , 邓德志，等 . 装药结构对灭火弹灭火剂抛撒影响研究 [J]. 弹箭与制导学报 , 2020 , 40 （ 4 ）: 85 ⁃ 88 .

ZHU Cong , LIANG Zengyou , DENG Dezhi , et al . The influence of charge structure on detonation of fire extinguishing agent [J]. Journal of Projectiles ,Rockets,Missiles and Guidance, 2020 , 40 （ 4 ）: 85 ⁃ 88 . （in Chinese）

刘刚 . 气动发射式高层建筑灭火炮研究 [D]. 哈尔滨：哈尔滨工程大学 , 2012 .

LIU Gang . Reserch on pneumatic fire⁃extinguish cannon for high⁃rise building [D]. Harbin : Harbin Engineering University , 2012 . （in Chinese）

张亚东 , 熊敏 , 董明洋 , 等 . 电磁弹射灭火弹消防系统研究 [J]. 强激光与粒子束 , 2020 , 32 （ 2 ）: 127 ⁃ 132 .

ZHANG Yadong , XIONG Min , DONG Mingyang , et al . Research on the fire⁃fighting system of electromagnetic ejection fire extinguishing bomb [J]. High Power Laser and Particle Beams , 2020 , 32 （ 2 ）: 127 ⁃ 132 . （in Chinese）

姚磊 . 基于PAC的航弹投放系统研究 [D]. 哈尔滨：哈尔滨工程大学 , 2016 .

YAO Lei . Reserch on aerial bomb delivery system based on PAC [D]. Harbin : Harbin Engineering University , 2016 . （in Chinese）

LIU Wanli , CHEN Xiong , LI Yingkun . Numerical simulation on cold⁃flow impact of the soft pulse separation device in dual pulse solid rocket motor [J]. Journal of Physics:Conference Series , 2020 , 1510 （ 1 ）: 012016.1 ⁃ 012016.6 .

FRENCH A D , PANELLI M , DI LORENZO G , et al . Combustion instability and pressure oscillation numerical simulation in a solid rocket motor [R].AIAA 2017 ⁃4952 , 2017 .

FAVINI B , ZAGHI S , SERRAGLIA F , et al . 3D numerical simulation of ignition transient in SRM [R].AIAA 2006 ⁃4953 , 2006 .

汤亮 , 邓康清 , 余小波 , 等 . 隔舱式双脉冲发动机第Ⅱ脉冲点火过程数值仿真 [J]. 航空动力学报 , 2020 , 35 （ 7 ）: 1541 ⁃ 1548 .

TANG Liang , DENG Kangqing , YU Xiaobo , et al . Numerical simulation for the second pulse ignition progress in compartment dual⁃pulse motor [J]. Journal of Aerospace Power , 2020 , 35 （ 7 ）: 1541 ⁃ 1548 . （in Chinese）

孟亮飞 , 田发林 , 周长省 . 阶梯装药固体火箭发动机点火内流场特性研究 [J]. 弹箭与制导学报 , 2010 , 30 （ 5 ）: 127 ⁃ 130 .

MENG Liangfei , TIAN Falin , ZHOU Changsheng . Study on the characteristics of flow field in the ignition of stepped⁃charge solid rocket motor [J]. Journal of Projectiles ,Rockets,Missiles and Guidance, 2010 , 30 （ 5 ）: 127 ⁃ 130 . （in Chinese）

王珊珊 , 王浩 , 张博孜 , 等 . 大长径比、高密实火药床点火管点传火特性的影响因素 [J]. 爆炸与冲击 , 2014 , 34 （ 4 ）: 489 ⁃ 494 .

WANG Shanshan , WANG Hao , ZHANG Bozi , et al . Factors affecting the ignition of a large length⁃to⁃diameter ratio igniter tube filled with consolidated charge [J]. Explosion And Shock Waves , 2014 , 34 （ 4 ）: 489 ⁃ 494 . （in Chinese）

翁春生 , 王浩 . 计算内弹道学 [M]. 北京：国防工业出版社 , 2006 .

Views

下载量

CSCD

Alert me when the article has been cited

提交

Tools

Publicity Resources

Numerical simulation on effects of variable specific heat capacity on internal flow field of jet vector nozzle

Numerical investigation on internal flow of a spherical convergent flap nozzle with complex geometry

Simulation method of short crack propagation in turbine disks based on crystal plasticity

Numerical simulation for the second pulse ignition progress in compartment dual-pulse motor

Influence of throat diameter ratio of two-stage nozzle on gas-steam ejection parameters

Related Author

SONG Ya-fei

GAO Feng

WEN Ke

HE Zhi-lin

JIN Nan-nan

SONG Jie

WANG Qiang

Ping ZHANG

Related Institution

Missile Institute, Air Force Engineering University, Sanyuan Shanxi

School of Jet Propulsion, Beijing University of Aeronautics and Astronautics

School of Power and Energy，Northwestern Polytechnical University

Nondestructive Testing and Evaluation Laboratory， Dalian University of Technology

College of Civil Engineering， Hefei University of Technology

AI问答

Postal code：100079
Tel：（010）53879206 Email：tmw@bjxintong.com.cn
Technical support is provided by Beijing Founder electronics co., LTD 京ICP备09082226号-64 京公网安备11010602201714号
It is recommended to read the content of this site in Chrome&IE9+. Please switch to extreme mode in browser 360.
Cookies We use cookies to help provide and enhance our service and tailor content. By continuing, you agree to the use of cookies.

⁰