Analysis of control characteristics of airborne integrated thermal management system

Xu ZHOU; Chunying JIANG; Shengyu LI; Meng CHEN; Yan'e MAO

doi:10.13224/j.cnki.jasp.20200441

Chinese

您当前的位置：

首页 >

文章列表页 >

Analysis of control characteristics of airborne integrated thermal management system

Combustion,Heat and Mass Transfer | 更新时间：2025-04-07

- Analysis of control characteristics of airborne integrated thermal management system
- Journal of Aerospace Power Vol. 37, Issue 3, Pages: 511-522(2022)
- 作者机构：
  
  1.沈阳航空航天大学机电工程学院，沈阳 110136
  2.沈阳航空航天大学计算机学院，沈阳 110136
  3.中国航空工业集团有限公司沈阳飞机设计研究所，沈阳 110035
- 作者简介：
- 基金信息：
- DOI：10.13224/j.cnki.jasp.20200441
  CLC：
- 稿件说明：
移动端阅览
Xu ZHOU, Chunying JIANG, Shengyu LI, et al. Analysis of control characteristics of airborne integrated thermal management system[J]. Journal of Aerospace Power, 2022, 37(3): 511-522.
DOI：

Xu ZHOU, Chunying JIANG, Shengyu LI, et al. Analysis of control characteristics of airborne integrated thermal management system[J]. Journal of Aerospace Power, 2022, 37(3): 511-522. DOI： 10.13224/j.cnki.jasp.20200441.

摘要

以简化的机载综合热管理系统作为研究对象，对系统在不同控制模式下的变化特性进行分析，为系统控制方案的研究提供了理论依据。利用数学模型和计算机模型相结合的方法建立起一种以燃油为主要热沉，具有空气/燃油换热器、燃油/PAO（聚α烯烃）换热器等主要元器件的机载综合热管理系统整体模型，并提出一种模糊自整定的PID（比例⁃积分⁃微分）控制方法对燃油/PAO换热器和电子设备热变化等系统特性进行分析。结果表明：在热极限工况下，相对于开环控制，模糊自整定PID控制模式不仅能有效地控制燃油泵等一系列设备保持合适的转速，还可以保证电子舱及燃油/PAO换热器的出口温度保持在既定范围以内，进而满足机载综合热管理系统的设计要求。

Abstract

Taking the simplified airborne integrated thermal management system as the research object，the change characteristics of the system under different control modes were analyzed，which provided a theoretical basis for the study of system control schemes.Using a combination of mathematical models and computer models to establish an airborne integrated thermal management system model with fuel as the main heat sink，air/fuel heat exchanger，fuel/PAO （polymerized alpha olefin） heat exchanger and other main components，and a fuzzy self⁃tuning PID （proportional⁃integral⁃derivative） control method was proposed to analyze system characteristics such as fuel/PAO heat exchanger and electronic equipment thermal changes.The results show that compared to open⁃loop control under thermal extreme conditions，the fuzzy self⁃tuning PID control mode can not only effectively control a series of equipment such as fuel pumps to maintain proper speed，but also ensure the electronic cabin and fuel/PAO heat exchanger.The outlet temperatures are kept within a predetermined range to meet the design requirements of the airborne integrated thermal management system.

关键词

Keywords

references

LI D , DONG S , WANG J , et al . Thermal dynamics and thermal management strategy for a civil aircraft hydraulic system [J]. Thermal Science Journal , 2020 , 24 （ 4 ）: 2311 ⁃ 2318 .

孙宇 . 大型无人机整体热环境三维动态仿真分析 [D]. 哈尔滨：哈尔滨工业大学 , 2015 .

SUN Yu . Three⁃dimensional dynamic simulation analysis of the overall thermal environment of a large UAV [D]. Harbin : Harbin Institute of Technology , 2015 . （in Chinese）

庞丽萍 , 邹凌宇 , 阿嵘 , 等 . 高速运载器燃油热管理系统优化 [J]. 北京航空航天大学学报 , 2019 , 45 （ 2 ）: 252 ⁃ 258 .

PANG Liping , ZOU Lingyu , A Rong , et al . Optimization of fuel thermal management system for high⁃speed carrier [J]. Journal of Beijing University of Aeronautics and Astronautics , 2019 , 45 （ 2 ）: 252 ⁃ 258 . （in Chinese）

WALTERS E A , IDEN S , IDEN S , MCCARTHY K , et al . Modeling INVENT , simulation , analysis and optimization [R]. AIAA⁃2010⁃287 , 2010 .

IDEN S . Integrated vehicle energy technology overview [R]. Cincinnati,US : Air Force Research Laboratory , 2012 .

WEISE P , GVOZDICH G , VON SPAKOVSKY M . INVENT:mission⁃integrated optimization of a tip⁃to⁃tail high performance aircraft system [R]. AIAA⁃2012⁃0491 , 2012 .

孙友师 , 俞笑 , 黄铁山 . 美国空军能量优化飞机研究进展综述 [C]∥ 2017年（第三届）中国航空科学技术大会论文集（下册） . 北京 : 中国航空学会 , 2017 : 38 ⁃ 41 .

徐志英 , 庄达民 . 飞机燃油系统热管理研究 [J]. 航空动力学报 , 2007 , 22 （ 11 ）: 1833 ⁃ 1837 .

XU Zhiying , ZHUANG Damin . Research on thermal management of aircraft fuel system [J]. Journal of Aerospace Power , 2007 ， 22 （ 11 ）: 1833 ⁃ 1837 . （in Chinese）

马德胜 , 庞丽萍 , 毛晓东，等 . 机载综合环控系统的热管理 [J]. 化工学报 , 2020 , 71 （增刊1 ）: 436 ⁃ 440 .

MA Desheng , PANG Liping , MAO Xiaodong , et al . Thermal management of airborne integrated environmental control system [J]. Journal of Chemical Industry and Engineering , 2020 , 71 （ Suppl.1 ）: 436 ⁃ 440 . （in Chinese）

于喜奎，毛羽丰 . 高超声速飞机热管理系统控制模型构建与仿真 [J]. 航空动力学报， 2018 ， 33 （ 3 ）: 741 ⁃ 751 .

YU Xikui , MAO Yufeng . Construction and simulation of the control model for the thermal management system of a hypersonic aircraft [J]. Journal of Aerospace Power , 2018 , 33 （ 3 ）: 741 ⁃ 751 . （in Chinese）

于喜奎 , 王伟 . 飞机综合机电系统热管理技术浅析 [J]. 飞机设计 , 2006 （ 2 ）: 60 ⁃ 62,71 .

YU Xikui , WANG Wei . Analysis on thermal management technology of aircraft integrated electromechanical system [J]. Aircraft Design , 2006 （ 2 ）: 60 ⁃ 62,71 . (in Chinese)

LABECKAS G , SLAVINSKAS S . Combustion phenomenon,performance and emissions of a diesel engine with aviation turbine JP⁃8 fuel and rapeseed biodiesel blends [J]. Energy Conversion and Management , 2015 , 105 : 216 ⁃ 229 .

刘伟 . PAO生产军用航空润滑油研究 [J]. 精细与专用化学品 , 2018 , 26 （ 2 ）: 18 ⁃ 21 .

LIU Wei . Study on the production of military aviation lubricating oil by PAO [J]. Fine and Special Chemicals , 2018 , 26 （ 2 ）: 18 ⁃ 21 . （in Chinese）

屠敏 , 袁耿民 , 薛飞 , 等 . 综合热管理在先进战斗机系统研制中的应用 [J]. 航空学报 , 2020 , 41 （ 6 ）: 136 ⁃ 146 .

TU Min , YUAN Gengmin , XUE Fei , et al . Application of integrated thermal management in the development of advanced fighter systems [J]. Acta Aeronautica et Astronautica Sinica , 2020 , 41 （ 6 ）: 136 ⁃ 146 . （in Chinese）

黄星 . 飞机自适应动力与热管理系统能效分析研究 [D]. 南京：南京航空航天大学 , 2018 .

HUANG Xing . Energy efficiency analysis of aircraft adaptive power and thermal management system [D]. Nanjing : Nanjing University of Aeronautics and Astronautics , 2018 . （in Chinese）

马慧才 , 刘毅玲 , 党晓民 . 高空长航时无人机综合热能管理的构型分析 [J]. 化工学报 , 2020 , 71 （增刊1 ）: 417 ⁃ 424 .

MA Huicai , LIU Yiling , DANG Xiaomin . Configuration analysis of integrated thermal energy management for UAVs at high altitude and long endurance [J]. Journal of Chemical Industry and Engineering , 2020 , 71 （ Suppl.1 ）: 417 ⁃ 424 . （in Chinese）

孟繁鑫 , 孙佳宁 , 周月 , 等 . 飞机环控系统空气循环机仿真建模及试验校核 [J]. 化工学报 , 2020 , 71 （增刊1 ）: 328 ⁃ 334 .

MENG Fanxin,SUN Jianing,ZHOU Yue,et al Simulation modeling and test verification of air circulation machine for aircraft environmental control system [J]. Journal of Chemical Industry and Engineering , 2020 , 71 （ Suppl.1 ）: 328 ⁃ 334 . （in Chinese）

LIU Zhi , WANG Yong . Fuzzy adaptive tracking control within the full envelope for an unmanned aerial vehicle [J]. Chinese Journal of Aeronautics , 2014 , 27 （ 5 ）: 1273 ⁃ 1287 .

Views

下载量

CSCD

Alert me when the article has been cited

提交

Tools

Publicity Resources

组合式弹性金属密封泄漏特性实验研究与结构优化

考虑多源不确定性的复合材料风扇叶片高周疲劳失效概率评估

基于三维接触摩擦单元的套齿连接解析建模研究

与发动机匹配的旁路式双喉道气动矢量喷管数值模拟研究

基于自适应MOMEDA滚动轴承故障特征提取方法

Related Author

No data

Related Institution

No data

AI问答

Postal code：100079
Tel：（010）53879206 Email：tmw@bjxintong.com.cn
Technical support is provided by Beijing Founder electronics co., LTD 京ICP备09082226号-64 京公网安备11010602201714号
It is recommended to read the content of this site in Chrome&IE9+. Please switch to extreme mode in browser 360.
Cookies We use cookies to help provide and enhance our service and tailor content. By continuing, you agree to the use of cookies.

⁰