Heat transfer and flow resistance characteristics of multi⁃row jet impingement cooling in double⁃wall cooling structure

Hong WEI; Yingqing ZU

doi:10.13224/j.cnki.jasp.20200486

Chinese

您当前的位置：

首页 >

文章列表页 >

Heat transfer and flow resistance characteristics of multi⁃row jet impingement cooling in double⁃wall cooling structure

Combustion, Heat and Mass Transfer | 更新时间：2025-04-07

- Heat transfer and flow resistance characteristics of multi⁃row jet impingement cooling in double⁃wall cooling structure
- Journal of Aerospace Power Vol. 36, Issue 8, Pages: 1621-1632(2021)
- 作者机构：
  
  1.复旦大学航空航天系，上海 200433
  2.上海交通大学机械与动力工程学院，上海 200240
- 作者简介：
- 基金信息：
- DOI：10.13224/j.cnki.jasp.20200486
  CLC：
- 稿件说明：
移动端阅览
Hong WEI, Yingqing ZU. Heat transfer and flow resistance characteristics of multi⁃row jet impingement cooling in double⁃wall cooling structure[J]. Journal of Aerospace Power, 2021, 36(8): 1621-1632.
DOI：

Hong WEI, Yingqing ZU. Heat transfer and flow resistance characteristics of multi⁃row jet impingement cooling in double⁃wall cooling structure[J]. Journal of Aerospace Power, 2021, 36(8): 1621-1632. DOI： 10.13224/j.cnki.jasp.20200486.

摘要

采用稳态热敏液晶技术对双层壁冷却结构中的多排（包括顺排和叉排）射流冲击冷却结构进行了风洞实验，同时结合数值模拟的方法，对两种射流冲击冷却结构的传热和流阻特性的差异进行了研究。实验结果表明：流量系数和冲击靶板上的努塞尔数均随着雷诺数的增大而增大，而冲击孔的排布方式对面平均努塞尔数的影响较小，但是叉排结构的流量系数高于顺排结构，且冲击靶板上换热更加均匀。数值结果显示冲击靶板中心区域的流量分配和换热均随着冲击距离的增大而增大；而在下游区域内恰好与之相反。

Abstract

The heat transfer and flow resistance characteristics of the jet impingement cooling in double-wall cooling structure were experimentally and numerically studied.The cooling structure with inline and staggered patterns were experimentally studied in the wind tunnel with steady-state thermo-chromic liquid crystal technology，and the differences of heat transfer and flow resistance characteristics of two structures were studied.The experimental results indicated that both the discharge coefficient and Nusselt number on the target plate increased with the increase of Reynolds number，and the influence of impingement hole arrangement on the averaged Nusselt number was small.However，the discharge coefficient of the staggered cooling structure was higher than that of the inline pattern，and the heat transfer on the target plate was more uniform.Furthermore，the numerical results showed that distribution of the mass flow rate and the heat transfer in the central region of target plate increased with the increase of impact distance，while the opposite phenomenon occurred in the downstream area.

关键词

Keywords

references

HAM J C , DUTTA S , EKKAD S . Gas turbine heat transfer and cooling technology [M]. 2nd ed . New York ： Taylor & Francis Group ， 2012 ： 14 - 67 .

LEE J , REN Z , LIGRANI P , et al . Crossflows from jet array impingement cooling:hole spacing,target plate distance,Reynolds number effects [J]. International Journal of Thermal Sciences , 2015 , 88 : 7 - 18 .

JANG J H , CHUI H C , YAN W M . Impinging cooling of film hole surface using transient liquid crystal thermograph [J]. International Communication in Heat and Mass Transfer , 2013 , 44 : 23 - 30 .

FECHTER S , TERZIS A , OTT P , et al . Experimental and numerical investigation of narrow impingement cooling channels [J]. International Journal of Heat and Mass Transfer , 2013 , 67 : 1208 - 1219 .

RAO Y , LIU Y Y , WAN C Y . Multiple-jet impingement heat transfer in double wall cooling structures with pin fins and effusion holes [J]. International Journal of Thermal Sciences , 2018 , 133 : 106 - 119 .

LIU H Y , KONG M Z , LIU S L , et al . The effect of jet array arrangement on the flow characteristics of the outlet hole in short confined channels [J]. Heat Transfer , 2008 , 37 （ 1 ）: 20 - 28 .

CHEN L L , BRAKMANN R G A , WEIGAND B , et al . Experimental and numerical heat transfer investigation of an impingement jet array with V-ribs on the target plate and on the impingement plate [J]. International Journal of Heat and Fluid Flow , 2017 , 68 : 126 - 138 .

LI X Y , REN J , JIANG H D . Film cooling effectiveness distribution of cylindrical hole injections at different locations on a vane endwall [J]. International Journal of Heat and Mass Transfer , 2015 , 90 : 1 - 14 .

KIM S H , AHN K H , PARK J S , et al . Local heat and mass transfer measurements for multi-layered impingement/effusion cooling:Effects of pin spacing on the impingement and effusion plate [J]. International Journal of Heat and Mass Transfer , 2017 , 105 : 712 - 722 .

LIU H Y , LIU S L , QIANG H F , et al . Aerodynamic investigation of impingement cooling in a confined channel with staggered jet array arrangement [J]. Experimental Thermal and Fluid Science , 2013 , 48 : 184 - 197 .

REN Z , VANGA S R , ROGERS N , et al . Internal and external cooling of a full coverage effusion cooling plate:effects of double wall configuration and conditions [J]. International Journal of Thermal Sciences , 2018 , 124 : 36 - 49 .

MENSCH A , THOLE K A . Conjugate heat transfer analysis of the effects of impingement channel height for a turbine blade endwall [J]. International Journal of Heat and Mass Transfer , 2015 , 82 : 66 - 77 .

TAN X M , ZHANG J Z , XU H S . Experimental investigation on impingement/effusion cooling with short normal injection holes [J]. International Communications in Heat and Mass Transfer , 2015 , 69 : 1 - 10 .

HONG S K , LEE D H , CHO H H . Effect of jet direction on heat/mass transfer of rotating impingement jet [J]. Applied Thermal Engineering , 2009 , 29 （ 14/15 ）: 2914 - 2920 .

HONG S K , LEE D H , CHO H H , et al . Local heat/mass transfer measurements on effusion plates in impingement/effusion cooling with rotation [J]. International Journal of Heat and Mass Transfer , 2010 , 53 : 1373 - 1379 .

QU L H , ZHANG J Z , TAN X M , et al . Numerical investigation on adiabatic film cooling effectiveness and heat transfer coefficient for effusion cooling over a transverse corrugated surface [J]. Chinese Journal of Aeronautics , 2017 , 30 （ 2 ）: 677 - 684 .

KHALATOV A A , PANCHENKO N A , SEVERIN S D . Application of cylindrical,triangular and hemispherical dimples in the film cooling technology [J]. Journal of Physics:Conference Series , 2017 , 891 （ 1 ）: 012145.1 ⁃ 012145.6 .

ZHANG J Z , ZHU X D , HUANG Y , et al . Investigation on film cooling performance from a row of round-to-slot holes on flat plate [J]. International Journal of Thermal Sciences , 2017 , 118 : 207 - 225 .

MOFFAT R J . Describing the uncertainties in experimental results [J]. Experimental Thermal and Fluid Science , 1988 , 1 （ 1 ）: 3 - 17 .

张泽远 . 半封闭通道内冲击射流换热特性和流量系数的实验研究 [D]. 南京：南京航空航天大学， 2006 .

ZHANG Zeyuan . Experiment study of convective heat transfer and discharge coefficient of jet impingement inside semi-confined channel [D]. Nanjing : Nanjing University of Aeronautics and Astronautics , 2016 . （in Chinese）

张泽远 , 张靖周 , 杨卫华 . 半封闭通道射流冲击孔流量系数的实验 [J]. 航空动力学报 , 2009 , 24 （ 6 ）: 1270 - 1274 .

ZHANG Zeyuan , ZHANG Jingzhou , YANG Weihua . Experimental investigation on discharge coefficient of jet impingement holes within semi-confined channel [J]. Journal of Aerospace Power , 2009 , 24 （ 6 ）: 1270 - 1274 . （in Chinese）

Views

下载量

CSCD

Alert me when the article has been cited

提交

Tools

Publicity Resources

Experiment of Reynolds number effects on subsonic compressor plane cascade

Film cooling performance and flow resistance characteristics of single/triple⁃row fan⁃shaped holes based on actual density ratio

Experiment on discharge coefficients for outlet lateral dilated hole

Effect of Venturi length on flow field and spray characterization of dual axial swirler

Impact of Reynolds number on unsteady flow in axial flow compressor rotor

Related Author

Wei WEI

Siyuan REN

Husheng MA

Xuechen LI

Youhai ZONG

Buming WAN

Jun CAO

Chaochao LI

Related Institution

Aerospace Technology Institute，China Aerodynamics Research and Development Center

Hunan Aviation Powerplant Research Institute， Aero Engine Corporation of China

Hunan Aviation Powerplant Research Institute, Aero Engine Corporation of China

天津大学机械工程学院

中国航空发动机集团有限公司湖南动力机械研究所

AI问答

Postal code：100079
Tel：（010）53879206 Email：tmw@bjxintong.com.cn
Technical support is provided by Beijing Founder electronics co., LTD 京ICP备09082226号-64 京公网安备11010602201714号
It is recommended to read the content of this site in Chrome&IE9+. Please switch to extreme mode in browser 360.
Cookies We use cookies to help provide and enhance our service and tailor content. By continuing, you agree to the use of cookies.

⁰