Design and test of temperature distortion generator on small flow rate compressor

Jun ZHANG; Ling ZHU; Jiancheng SHI; Guowen WANG; Yueqian YIN

doi:10.13224/j.cnki.jasp.20210068

Chinese

您当前的位置：

首页 >

文章列表页 >

Design and test of temperature distortion generator on small flow rate compressor

Turbomachinery | 更新时间：2025-04-07

- Design and test of temperature distortion generator on small flow rate compressor
- Journal of Aerospace Power Vol. 37, Issue 1, Pages: 173-180(2022)
- 作者机构：
  
  中国航空发动机集团有限公司湖南动力机械研究所中小型航空发动机叶轮机械湖南省重点实验室，湖南株洲 412002
- 作者简介：
- 基金信息：
- DOI：10.13224/j.cnki.jasp.20210068
  CLC：
- 稿件说明：
移动端阅览
Jun ZHANG, Ling ZHU, Jiancheng SHI, et al. Design and test of temperature distortion generator on small flow rate compressor[J]. Journal of Aerospace Power, 2022, 37(1): 173-180.
DOI：

Jun ZHANG, Ling ZHU, Jiancheng SHI, et al. Design and test of temperature distortion generator on small flow rate compressor[J]. Journal of Aerospace Power, 2022, 37(1): 173-180. DOI： 10.13224/j.cnki.jasp.20210068.

摘要

利用电加热管设计了小流量压气机温度畸变发生器，针对某小流量压气机的温度畸变要求，对温度畸变发生器进行畸变指数标定试验，得到满足温度畸变指数要求的畸变发生器运行参数、总压恢复系数和总压畸变指数；将温度畸变发生器安装至压气机试验件，进行压气机性能试验，得到压气机在温度畸变条件下的气动性能。结果表明：满足温度畸变指数要求的电加热管需运行4~5根，单根功率为3 kW，进口物理流量需不大于3 kg/s；在该畸变发生器运行参数下，压气机峰值效率最大下降了1.3%，喘振边界无明显影响。

Abstract

A small flow compressor temperature distortion generator was designed by using electric heating tubes.The operation parameters of the temperature distortion generator were calibrated with temperature distortion coefficient，and the total pressure recovery coefficient and pressure distortion coefficient were obtained.The temperature distortion generator was installed on the compressor test rig，and the aerodynamic performance of the compressor under the condition of temperature distortion was obtained.The results showed that 4-5 electric heating tubes were required to meet the requirements of temperature distortion coefficient，and the power of a single tube was 3 kW.The inlet physical mass flow must be less than 3 kg/s.Under the operating parameters of the distortion generator，the peak efficiency of the compressor decreased by 1.3% at most，and the surge line had no significant change.

关键词

Keywords

references

刘博强 . 小流量温度畸变发生器设计及温度畸变特性研究 [D]. 南京 : 南京航空航天大学， 2016 .

LIU Boqiang . Investigation on design and temperature distortion characteristic of small flow temperature distortion generator [D]. Nanjing : Nanjing University of Aeronautics and Astronautics , 2016 . （in Chinese）

CHILDS J H , KOCHENDORFER F D , LUBICK R J , et al . Stall and flame⁃out resulting from firing of armament [R]. Washington : National Advisory Committee for Aeronautics , 1955 .

DIPIETRO A L . Design and experimental evaluation of a dynamic thermic distortion generator for turbomachinery research [D]. Blacksburg,Virginia : Virginia Polytechnic Institute and State University , 1993 .

张明川 , 张津 , 唐狄毅 . 均匀和畸变进气条件下轴流压气机失速分析 [J]. 北京航空航天大学学报 , 1998 , 24 （ 6 ）: 704 ⁃ 706 .

ZHANG Mingchuan , ZHANG Jin , TANG Diyi . Analysis of axial flow compressors stall in uniform and distorted inlet flow [J]. Journal of Beijing University of Aeronautics and Astronautics , 1998 , 24 （ 6 ）: 704 ⁃ 706 . （in Chinese）

王掩刚 , 先松川 , 国睿 . 周向总压畸变对对转压气机影响效应分析 [J]. 推进技术 , 2015 , 36 （ 2 ）: 200 ⁃ 206 .

WANG Yangang , XIAN Songchuan , GUO Rui . Effects of circumferential total pressure distortion on flow field in a contra⁃rotating axial compressor [J]. Journal of Propulsion Technology , 2015 , 36 （ 2 ）: 200 ⁃ 206 . （in Chinese）

王勤 , 刘世官 , 王振华 . 某型发动机进气总压畸变流场中涡旋尺度的计算及其变化特征 [J]. 航空发动机 , 2003 , 29 （ 2 ）: 29 ⁃ 33 .

WANG Qin , LIU Shiguan , WANG Zhenhua . Characteristie and calculation of eddy scale in total pressure distortion flow at typical engine inlet [J]. Aeroengine , 2003 , 29 （ 2 ）: 29 ⁃ 33 . （in Chinese）

DAVE B , SCOTT W , JIM R , et al . Demonstration of a transient total⁃pressure distortion generator for simulating aircraft inlet distortion in turbine engine ground tests [R]. ASME Paper GT2007⁃27222 , 2007 .

YOGI S , BRUCE B , ROBERT H , et al . A centrifugal compressor operability correlation with combined total pressure and swirl distortion [R]. ASME Paper GT2017⁃63721 , 2017 .

程邦勤 , 王加乐 , 冯路宁 . 航空发动机进气旋流畸变研究综述 [J]. 航空动力学报 , 2020 , 35 （ 12 ）: 2465 ⁃ 2481 .

CHEN Bangqin , WANG Jiale , FENG Luning . Review of aero⁃engine inlet swirl distortion research [J]. Journal of Aerospace Power , 2020 , 35 （ 12 ）: 2465 ⁃ 2481 . （in Chinese）

王俊琦 , 汪涛 , 刘雨 , 等 . 尾喷流吸入对发动机进气畸变的影响 [J]. 航空动力学报 , 2021 , 36 （ 1 ）: 97 ⁃ 103 .

WANG Junqi , WANG Tao , LIU Yu , et al . Influence of exhaust gas ingestion on engine inlet distortion [J]. Journal of Aerospace Power , 2021 , 36 （ 1 ）: 97 ⁃ 103 . （in Chinese）

滕健 . S弯进气道温度畸变特性及其对小流量涡喷发动机的影响 [D]. 福建厦门：厦门大学 , 2018 .

TENG Jian . Temperature distortion characteristics in S⁃duct inlet and its influence on micro jet engine [D]. Xiamen,Fujian ： Xiamen University , 2018 . （in Chinese）

李丹 . 进口流场温度畸变对航空发动机性能影响研究 [D]. 成都：电子科技大学 , 2009 .

LI Dan . Research of inlet temperature distortion influence on jet engine [D]. Chengdu ： University of Electronic Science and Technology of China , 2009 . （in Chinese）

尤延铖 , 滕健 , 郑晓刚 , 等 . 航空发动机进气温度畸变研究综述 [J]. 南京航空航天大学学报 , 2017 , 49 （ 3 ）: 283 ⁃ 300 .

YOU Yancheng , TENG Jian , ZHENG Xiaogang , et al . Review of aero⁃engine temperature distortion research [J]. Nanjing:Journal of Nanjing University of Aeronautics and Astronautics , 2017 , 49 （ 3 ）： 283 ⁃ 300 . （in Chinese）

罗玛 , 李建中 , 向立军 , 等 . 小流量温度畸变发生器工作特性试验研究 [J]. 推进技术 , 2017 , 38 （ 12 ）: 2836 ⁃ 2842 .

LUO Ma , LI Jianzhong , XIANG Lijun , et al . Experimental investigation on operating characteristic of small flow rate temperature distortion generator [J]. Journal of Propulsion Technology , 2017 , 38 （ 12 ）: 2836 ⁃ 2842 . （in Chinese）

王润明 , 王惠儒 , 侯敏杰 , 等 . 温度畸变发生器研制 [J]. 燃气涡轮试验与研究 , 2002 , 15 （ 2 ）: 41 ⁃ 46 .

WANG Runming , WANG Huiru , HOU Minjie , et al . Design and development of temperature distortion generator [J]. Gas Turbine Experiment and Research , 2002 , 15 （ 2 ）: 41 ⁃ 46 . （in Chinese）

刘大响 , 叶培梁 . 温度畸变发生器的功用及其试验方法 [J]. 燃气涡轮试验与研究 , 1999 , 12 （ 2 ）: 58 ⁃ 62 .

LIU Daxiang , YE Peiliang . Function and test method of a temperature distortion generator [J]. Gas Turbine Experiment and Research , 1999 ， 12 （ 2 ）: 58 ⁃ 62 . （in Chinese）

侯敏杰 , 刘大响 , 王惠儒 . 温度畸变发生器的设计与实验 [J]. 航空动力学报 , 2005 , 20 （ 3 ）: 361 ⁃ 367 .

HOU Minjie , LIU Daxiang , WANG Huiru . Design and experimental study of the inlet temperature distortion generator [J]. Journal of Aerospace Power , 2005 , 20 （ 3 ）: 361 ⁃ 367 . （in Chinese）

叶培梁 , 刘大响 . 进口温度畸变对涡扇发动机稳定性影响的试验研究 [J]. 燃气涡轮试验与研究 , 2001 , 14 （ 1 ）: 38 ⁃ 45 .

YE Peiliang , LIU Daxiang . An experiment investigation in effects of inlet temperature distortion on turbofan stability [J]. Gas Turbine Experiment and Research , 2001 , 14 （ 1 ）: 38 ⁃ 45 . （in Chinese）

Views

下载量

CSCD

Alert me when the article has been cited

提交

Tools

Publicity Resources

Compressor transient responses and stability at pulsating backpressure conditions

Time-frequency analysis of unsteady flow in centrifugal compressor

Experiment on inlet flow field of turbocharger centrifugal compressor under pulsating backpressure,

Influence of form of tip gap on aerodynamic performance of centrifugal compressor using mixture of helium and xenon

Analysis on interaction between centrifugal compressor and ,pulse detonation combustor

Related Author

Mengying SHU

Mingyang YANG

Xingchen WANG

Kangyao DENG

WU Wei

ZHAO Bo

XUE Xiang

ZHANG Kaiyue

Related Institution

School of Mechanical Engineering，Shanghai Jiao Tong University

中国船舶重工集团有限公司重庆江增船舶重工有限公司

哈尔滨工程大学动力与能源工程学院

中国科学院大学工程科学学院

中国科学院工程热物理研究所

AI问答

Postal code：100079
Tel：（010）53879206 Email：tmw@bjxintong.com.cn
Technical support is provided by Beijing Founder electronics co., LTD 京ICP备09082226号-64 京公网安备11010602201714号
It is recommended to read the content of this site in Chrome&IE9+. Please switch to extreme mode in browser 360.
Cookies We use cookies to help provide and enhance our service and tailor content. By continuing, you agree to the use of cookies.

⁰