Simulation of water hammer in liquid nitrogen supplying system based on AMESim

Wei ZHANG; Dewen SUN; Wanhua CHEN; Rong GAO; Jianye CHEN; Junlong XIE

doi:10.13224/j.cnki.jasp.20210098

Chinese

您当前的位置：

首页 >

文章列表页 >

Simulation of water hammer in liquid nitrogen supplying system based on AMESim

Combustion,Heat and Mass Transfer | 更新时间：2025-04-07

- Simulation of water hammer in liquid nitrogen supplying system based on AMESim
- Journal of Aerospace Power Vol. 37, Issue 2, Pages: 366-374(2022)
- 作者机构：
  
  1.中国空气动力研究与发展中心设备设计及测试技术研究所，四川绵阳 621000
  2.国防科技大学空天科学学院，长沙 410073
  3.华中科技大学能源与动力工程学院，武汉 430074
- 作者简介：
- 基金信息：
- DOI：10.13224/j.cnki.jasp.20210098
  CLC：
- 稿件说明：
移动端阅览
Wei ZHANG, Dewen SUN, Wanhua CHEN, et al. Simulation of water hammer in liquid nitrogen supplying system based on AMESim[J]. Journal of Aerospace Power, 2022, 37(2): 366-374.
DOI：

Wei ZHANG, Dewen SUN, Wanhua CHEN, et al. Simulation of water hammer in liquid nitrogen supplying system based on AMESim[J]. Journal of Aerospace Power, 2022, 37(2): 366-374. DOI： 10.13224/j.cnki.jasp.20210098.

摘要

基于系统级仿真平台AMESim，建立了大型低温风洞（CWT）液氮供给系统（LNSS）的动态仿真模型。实验对比结果显示，仿真结果的平均误差在6.8%以内，验证了模型的准确性，并进一步对比开展了喷嘴瞬时全关和喷嘴有序关闭两种典型工况下的液击分析。结果表明液击模型能够较好地反映管路系统中的液击过程。喷嘴瞬时全关工况下，液击峰值压力可达2.98 MPa；而当喷嘴分四组有序关闭时，液击峰值压力能有效降低，峰值压力为2.3 MPa且出现在最后一组喷嘴关闭时。同时，傅里叶分析（FFT）表明液击发生时压力波动存在一定周期性，且由多种频率组成，但喷嘴关闭模式对频率几乎没有影响。仿真研究结果可为大型低温风洞液氮供给系统提供设计校核和安全运行支撑。

Abstract

A dynamic model of liquid nitrogen supplying system （LNSS） for a large cryogenic wind tunnel （CWT） was built based on the advanced modeling environment for simulation of engineering systems （AMESim） platform.The accuracy of the model was verified by the experimental data with the mean deviation less than 6.8%.Accordingly，numerical simulation on water hammer was carried out under two working conditions of instantaneously complete close⁃down and orderly close⁃down of the nozzles at the end of the LNSS.Numerical results illustrated that the dynamic model can characterize the features of water hammer in the complex LNSS.The peak pressure at water hammer reached 2.98 MPa under the condition of instantaneous close⁃down of all the nozzles.By contrast

the peak pressure reached maximum with the value of 2.3 MPa at the last close⁃down when the nozzles were shut down orderly following four steps.Moreover，fast fourier transform （FFT） analysis illustrated that different frequencies existed in the pressure fluctuations during water hammering.However

the frequencies showed inconspicuous distinct under these two working conditions.The simulation results provide a support for the design check and safe operation of the large CWT.

关键词

Keywords

references

GREEN J , QUEST J . A short history of the European transonic wind tunnel ETW [J]. Progress in Aerospace Sciences , 2011 , 47 （ 5 ）: 319 ⁃ 368 .

周廷波，高超，张正科，等 . NF⁃6风洞喷液氮降温系统研制 [J]. 航空动力学报 , 2018 , 33 （ 2 ）: 327 ⁃ 337 .

ZHOU Tingbo , GAO Chao , ZHANG Zhengke , et al . Development of liquid nitrogen injection cooling system of NF⁃6 wind tunnel [J]. Journal of Aerospace Power , 2018 , 33 （ 2 ）: 327 ‑ 337 . （in Chinese）

孙皖，徐涛，刘秀芳，等 . 凝结相变对低温风洞雷诺数试验的影响 [J]. 航空动力学报 , 2020 , 35 （ 9 ）: 1893 ⁃ 1899 .

SUN Wan , XU Tao , LIU Xiufang , et al . Effect of condensation phase transient on Reynold number test for cryogenic wind tunnel [J]. Journal of Aerospace Power , 2020 , 35 （ 9 ）: 1893 ⁃ 1899 . （in Chinese）

陈振华，张伟，高荣，等 . 液氮抽真空制冷的理论及试验 [J]. 航空动力学报 , 2019 , 34 （ 9 ）: 1971 ⁃ 1976 .

CHEN Zhenhua , ZHANG Wei , GAO Rong , et al . Theoretical and experiment studies of vacuum cooling of liquid nitrogen [J]. Journal of Aerospace Power , 2019 , 34 （ 9 ）: 1971 ⁃ 1976 . （in Chinese）

黄知龙，周平，顾正华 . 大型低温风洞中的测控技术设计需求 [C]∥ 中国空气动力学会测控专业委员会第6届6次全国学术交流会论文集 . 广东惠州 : 中国空气动力学会 , 2015 : 168 ⁃ 171 .

廖达雄，黄知龙，陈振华，等 . 大型低温高雷诺数风洞及其关键技术综述 [J]. 实验流体力学 , 2014 , 28 （ 2 ）: 1 ⁃ 6 .

LIAO Daxiong , HUANG Zhilong , CHEN Zhenhua , et al . Review on large⁃scale cryogenic wind tunnel and key technologies [J]. Journal of Experiments in Fluid Mechanics , 2014 , 28 （ 2 ）: 1 ⁃ 6 . （in Chinese）

张伟，高荣，张双喜，等 . 0.3 m低温风洞液氮供给系统研制 [J]. 航空动力学报， 2020 , 35 （ 5 ）: 118 ⁃ 126 .

ZHANG Wei , GAO Rong , ZHANG Shuangxi , et al . Development of liquid nitrogen supplying system of 0.3m cryogenic wind tunnel [J]. Journal of Aerospace Power , 2020 , 35 （ 5 ）: 118 ⁃ 126 . （in Chinese）

GHIDAOUI M S , ZHAO M , MCINNIS D A , et al . A review of water hammer theory and practice [J]. Applied Mechanics Reviews , 2005 , 58 （ 1 ）: 49 ⁃ 76 .

MOORE W I , ARNOLD R J . Failure of Apollo Saturn V liquid oxygen loading system [C]∥ Advances in Cryogenic Engineering . Boston,US : Springer , 1995 : 533 ⁃ 544 .

刘照智，丁鹏飞，田青亚 . 液氢加注系统水击问题数值分析 [J]. 导弹与航天运载技术 , 2010 （ 4 ）: 10 ⁃ 12 .

LIU Zhaozhi , DING Pengfei , TIAN Qingya . Numerical analysis on water⁃hammer of liquid hydrogen loading system [J]. Missiles and Space Vehicles , 2010 （ 4 ）: 10 ⁃ 12 . （in Chinese）

王英浩 . 火箭推进剂输送系统中波纹管对水击压力的吸收分析 [D]. 长沙 : 国防科学技术大学 , 2004 .

WANG Yinghao . Analysis of bellows absorb water hammer in rocket propellant conveyer pipeline [D]. Changsha : National University of Defense Technology , 2004 . （in Chinese）

程谋森，刘昆，张育林 . 推进剂供应管路内液体瞬变流一维有限元计算 [J]. 推进技术 , 2000 , 21 （ 4 ）: 12 ⁃ 15 .

CHENG Mousen , LIU Kun , ZHANG Yulin . One⁃dimensional finite element solutions for liquid transients in propellant feedlines [J]. Journal of Propulsion Technology , 2000 , 21 （ 4 ）: 12 ⁃ 15 . （in Chinese）

ZHANG X X , CHENG Y G . Simulation of hydraulic transients in hydropower systems using the 1⁃D⁃3⁃D coupling approach [J]. Journal of Hydrodynamics , 2012 , 22 （ 4 ）: 595 ⁃ 604 .

KUMAR A , PRASAD S P , RAO M R . Experimental studies of water hammer in propellant feed system of reaction control system [J]. Propulsion and Power Research , 2018 , 7 （ 1 ）: 52 ‑ 59 .

AYED L , HAFSI Z . Revisiting frequency domain analysis method for water hammer effects on pipeline systems [J]. Journal of the Brazilian Society of Mechanical Sciences and Engineering ， 2020 , 42 （ 11 ）: 1 ⁃ 9 .

任孝文，陈宏玉，李平，等 . 弱可压缩流体与可压缩流体模型的管路水击研究 [J]. 推进技术， 2020 ， 41 （ 8 ）: 1880 ⁃ 1886 .

REN Xiaowen , CHEN Hongyu , LI Ping , et al . Investigation on water hammer in pipes by slightly compressible fluid model and compressible fluid model [J]. Journal of Propulsion Technology , 2020 , 41 （ 8 ）: 1880 ⁃ 1886 . （in Chinese）

DARR S R , HARTWIG J W . Two⁃phase convection heat transfer correlations for liquid hydrogen pipe chilldown [J]. Cryogenics , 2020 , 105 : 102999.1 ⁃ 102999.10 .

ISSELHORST A , SUSLOV D , RICCIUS J . Liquid hydrogen tests of a sub⁃scale launcher upper stage feed line evaporation cooler [J]. Acta Astronautica , 2019 , 158 : 231 ‑ 243 .

REN X W , LI P , CHEN H Y . Numerical simulation of water hammer in liquid methane feedline based on two compressible fluid models [J]. Cryogenics , 2020 , 109 : 103122.1 ⁃ 103122.8 .

MAJUMDAR A K , FLACHBART R H . Numerical modeling of fluid transients by a finite volume procedure for rocket propulsion systems [C]∥ Proceedings of ASME/JSME 2003 4th Joint Fluids Summer Engineering Conference . Honolulu,US : ASME , 2003 : 2967 ⁃ 2974 .

白晓瑞 . 液体火箭推进系统动态特性仿真研究 [D]. 长沙 : 国防科学技术大学 , 2008 .

BAI Xiaorui . Numerical analysis on dynamic characteristics of liquid rocket propulsion system [D]. Changsha : National University of Defense Technology , 2008 . （in Chinese）

晏政，刘泽军，程玉强，等 . 航天器推进系统模块化建模方法 [J]. 国防科技大学学报 , 2012 , 34 （ 4 ）: 28 ⁃ 32 .

YAN Zheng , LIU Zejun , CHENG Yuqiang , et al . Modular modeling of spacecraft propulsion system [J]. Journal of National University of Defense Technology , 2012 , 34 （ 4 ）: 28 ⁃ 32 . （in Chinese）

晏政，彭小辉，程玉强，等 . 航天器推进系统水击及其抑制方法 [J]. 航空动力学报 , 2012 , 27 （ 9 ）: 2028 ⁃ 2034 .

YAN Zheng , PENG Xiaohui , CHENG Yuqiang , et al . Research of water hammer and its suppression methods for spacecraft propulsion system [J]. Journal of Aerospace Power , 2012 , 27 （ 9 ）: 2028 ⁃ 2034 . （in Chinese）

张峥岳，康乃全 . 轨姿控液体火箭发动机水击仿真模拟 [J]. 火箭推进， 2012 , 38 （ 3 ）: 12 ⁃ 16 .

ZHANG Zhengyue , KANG Naiquan . Simulation of water hammer in liquid rocket engine of orbit and attitude control system [J]. Journal of Rocket Propulsion , 2012 , 38 （ 3 ）: 12 ⁃ 16 . （in Chinese）

赖欢，陈万华，孙德文，等 . 0.3 m低温连续式跨声速风洞结构设计 [J]. 实验流体力学 , 2020 , 34 （ 5 ）: 89 ⁃ 96 .

LAI Huan , CHEN Wanhua , SUN Dewen , et al . The structural design for 0.3 m cryogenic continuous transonic wind tunnel [J]. Journal of Experiments in Fluid Mechanics , 2020 , 34 （ 5 ）: 89 ⁃ 96 . （in Chinese）

刘海飞，陈虹，王天祥，等 . 液氢和液氧低温推进剂加注系统中的管路瞬变特性研究 [J]. 水动力学研究与进展A辑 , 2014 , 29 （ 6 ）: 642 ⁃ 648 .

LIU Haifei , CHEN Hong , WANG Tianxiang , et al . Study on the transient flow characteristics of the filling pipe of liquid hydrogen/liquid oxygen cryogenic propellants [J]. Chinese Journal of hydrodynamics , 2014 , 29 （ 6 ）: 642 ⁃ 648 . （in Chinese）

Views

下载量

CSCD

Alert me when the article has been cited

提交

Tools

Publicity Resources

Development of liquid nitrogen supplying system of 0.3 m cryogenic wind tunnel

Effect of condensation phase transient on Reynold number test for cryogenic wind tunnel

Spray and Combustion Investigation of Gas/Liquid Coaxial Injectors

基于自适应MOMEDA滚动轴承故障特征提取方法

考虑多源不确定性的复合材料风扇叶片高周疲劳失效概率评估

Related Author

ZHANG Wei

GAO Rong

ZHANG Shuangxi

SUN Wan

XU Tao

LIU Xiufan

Sun Jiguo

Tian Changyi

Related Institution

Beijing Fengyuan Machinery Inst.

National University of Defense Technology

AI问答

Postal code：100079
Tel：（010）53879206 Email：tmw@bjxintong.com.cn
Technical support is provided by Beijing Founder electronics co., LTD 京ICP备09082226号-64 京公网安备11010602201714号
It is recommended to read the content of this site in Chrome&IE9+. Please switch to extreme mode in browser 360.
Cookies We use cookies to help provide and enhance our service and tailor content. By continuing, you agree to the use of cookies.

⁰