Experimental study on thermal oxidation coking characteristics of aviation kerosene in additively manufactured helical tubes

Linqi ZHANG; Jie JIANG; Can RUAN; Xingcai LÜ

doi:10.13224/j.cnki.jasp.20210123

Chinese

您当前的位置：

首页 >

文章列表页 >

Experimental study on thermal oxidation coking characteristics of aviation kerosene in additively manufactured helical tubes

Combustion,Heat and Mass Transfer | 更新时间：2025-04-07

- Experimental study on thermal oxidation coking characteristics of aviation kerosene in additively manufactured helical tubes
- Journal of Aerospace Power Vol. 37, Issue 7, Pages: 1403-1412(2022)
- 作者机构：
  
  上海交通大学机械与动力工程学院，上海 200240
- 作者简介：
- 基金信息：
- DOI：10.13224/j.cnki.jasp.20210123
  CLC：
- 稿件说明：
移动端阅览
Linqi ZHANG, Jie JIANG, Can RUAN, et al. Experimental study on thermal oxidation coking characteristics of aviation kerosene in additively manufactured helical tubes[J]. Journal of Aerospace Power, 2022, 37(7): 1403-1412.
DOI：

Linqi ZHANG, Jie JIANG, Can RUAN, et al. Experimental study on thermal oxidation coking characteristics of aviation kerosene in additively manufactured helical tubes[J]. Journal of Aerospace Power, 2022, 37(7): 1403-1412. DOI： 10.13224/j.cnki.jasp.20210123.

摘要

为得到环境温度、入口雷诺数和磨粒流处理工艺对RP⁃3航空煤油氧化结焦特性的影响，针对增材制造（3D打印）螺旋圆管，采用了恒定环境温度的试验方法，开展了RP⁃3航空煤油热氧化结焦试验研究。试验结果表明：当入口雷诺数和试验时间保持恒定时，无论燃油处于静止还是流动状态，燃油结焦速率和总结焦量都随着环境温度的增加而增大；当试验件壁温和试验时间保持不变时，燃油处于流动状态下，燃油结焦速率和总结焦量随着入口雷诺数的增大呈现先增加后减少的变化趋势。采用磨粒流处理后，燃油在试验件内的结焦速率大于基准工况，总结焦量是基准工况下的1.17倍。对试验件内表面进行磨粒流处理不利于抑制结焦沉积。

Abstract

For the purpose of obtaining the influence of ambient temperature，inlet Reynolds number and abrasive flow treatment on the coking characteristics of RP⁃3 aviation kerosene，the RP⁃3 aviation kerosene thermal oxidation coking tests were carried out in additively manufactured （3D printed） helical tubes through the testing way of constant ambient temperature.The test results showed that when inlet Reynolds number and test time remained constant，the deposition rate and the total coking amount of the fuel increased with the increase of ambient temperature，regardless of whether the fuel was in a static or flowing state；when the fuel was in a flowing state，as inlet Reynolds number increased，the deposition rate increased first and then decreased with constant wall temperature and test time.After abrasive flow treatment，the deposition rate of the fuel in the test tube was greater than that of the fuel under baseline working condition，and the total coking amount of the fuel was 1.17 times the total coking amount of the fuel under baseline working condition.The abrasive flow treatment on the inner surface of the test tube was not conducive to the inhibition of coking deposition.

关键词

Keywords

references

廉筱纯，吴虎 . 航空发动机原理 [M]. 西安：西北工业大学出版社， 2005 .

BRUENING G B , CHANG W S . Cooled cooling air systems for turbine thermal management [R]. Indianapolis,Indian : International Gas Turbine & Aeroengine Congress & Exhibition , 1999 .

CHARLES E B , DAVID A B , STEPHEN M C , et al . Research on aviation fuel instability [R]. Cesme,Turkey : AGARD Propulsion and Energetics Panel Symposium on Combustion Problems in Turbine Engines , 1983 .

HAZLETT R N . Thermal oxidation stability of aviation turbine fuels [M]. Philadelphia，US : American Society for Testing and Materials , 1991 .

CHIN J S , LEFEBVRE A H . Temperature effects on fuel thermal stability [R]. Orlando，US : International Gas Turbine and Aeroengine Congress and Exposition , 1991 .

TAO Zhi , FU Yanchen , XU Guoqiang , et al . Experimental study on influences of physical factors to supercritical RP⁃3 surface and liquid⁃space thermal oxidation coking [J]. Energy & Fuels , 2014 , 28 （ 9 ）: 6098 ⁃ 6106 .

裴鑫岩 . 航空煤油超临界换热与氧化结焦理论与实验研究 [D]. 北京：清华大学 , 2016 .

PEI Xinyan . Numerical and experimental study of heat transfer characteristics and oxidation deposition of aviation kerosene at supercritical pressure [D]. Beijing : Tsinghua University , 2016 . （in Chinese）

刘天池 , 范育新 , 赵世龙，等 . 高温条件下RP⁃3航空煤油的结焦特性 [J]. 航空动力学报 , 2020 , 35 （ 2 ）: 348 ⁃ 357 .

LIU Tianchi , FAN Yuxin , ZHAO Shilong , et al . Deposition characteristics of RP⁃3 aviation kerosene under high temperature conditions [J]. Journal of Aerospace Power , 2020 , 35 （ 2 ）: 348 ⁃ 357 . （in Chinese）

SPADACCINI L J , SOBEL D R , HUANG H . Deposit formation and mitigation in aircraft fuels [J]. Journal of Engineering for Gas Turbines and Power , 2001 , 123 （ 4 ）: 741 ⁃ 746 .

COMPANY G E . Fuel nozzle for a gas turbine engine : US10591164b2 [P]. 2020⁃03⁃17 .

FU Yanchen , XU Guoqiang , WEN Jie , et al . Thermal oxidation coking of aviation kerosene RP⁃3 at supercritical pressure in helical tubes [J]. Applied Thermal Engineering , 2018 , 128 : 1186 ⁃ 1195 .

PEI Xinyan , HOU Lingyun . Secondary flow and oxidation coking deposition of aviation fuel [J]. Fuel , 2016 , 167 : 68 ⁃ 74 .

杨治，张净玉，姬鹏飞，等 . 典型管路RP⁃3航空煤油热氧化结焦特性试验研究 [J]. 推进技术 , 2020 , 41 （ 10 ）: 2374 ⁃ 2381 .

YANG Zhi , ZHANG Jingyu , JI Pengfei , et al . Experimental study on autoxidation coking characteristics of aviation kerosene RP⁃3 in typical pipeline [J]. Journal of Propulsion Technology , 2020 , 41 （ 10 ）: 2374 ⁃ 2381 . （in Chinese）

姬鹏飞 . 典型管路RP⁃3航空煤油热氧化结焦沉积特性研究 [D]. 南京：南京航空航天大学 , 2018 .

JI Pengfei . Research on autoxidation coking characteristics of aviation kerosene RP⁃3 in typical pipeline [D]. Nanjing : Nanjing University of Aeronautics and Astronautics , 2018 . （in Chinese）

TAO Zhi , FU Yanchen , XU Guoqiang , et al . Thermal and element analyses for supercritical RP⁃3 surface coke deposition under stable and vibration conditions [J]. Energy & Fuels , 2015 , 29 （ 3 ）: 2006 ⁃ 2013 .

JONES E G . Autoxidation of aviation fuels in heated tubes:surface effects [J]. Energy & Fuels , 1996 , 10 : 831 ⁃ 836 ..

王英杰 , 徐国强 , 邓宏武，等 . 进口温度影响航空煤油结焦特性实验 [J]. 航空动力学报 , 2009 , 24 （ 9 ）: 1972 ⁃ 1976 .

WANG Yingjie , XU Guoqiang , DENG Hongwu , et al . Experimental study of influence of inlet temperature on aviation kerosene coking characteristics [J]. Journal of Aerospace Power , 2009 , 24 （ 9 ）: 1972 ⁃ 1976 . （in Chinese）

琚印超 , 徐国强 , 郭隽，等 . 压力对航空煤油RP⁃3结焦的影响 [J]. 北京航空航天大学学报 , 2010 , 36 （ 3 ）: 257 ⁃ 260 .

JU Yinchao , XU Guoqiang , GUO Jun , et al . Effects of pressure on the coking characteristic of jet fuel RP⁃3 [J]. Journal of Beijing University of Aeronautics and Astronautics , 2010 , 36 （ 3 ）: 257 ⁃ 260 . （in Chinese）

常坤，梁恩泉，张韧，等 . 金属材料增材制造及其在民用航空领域的应用研究现状 [J]. 材料导报 , 2021 , 35 （ 3 ）: 3176 ⁃ 3182 .

CHANG Kun , LIANG Enquan , ZHANG Ren , et al . Status of metal additive manufacturing and its application research in the field of civil aviation [J]. Materials Reports , 2021 , 35 （ 3 ）: 3176 ⁃ 3182 . （in Chinese）

荀柏秋，李琦，赵乌恩 . 高温材料在燃气轮机中的应用和发展 [J]. 热能动力工程 , 2004 , 19 （ 5 ）: 447 ⁃ 449 .

XUN Baiqiu , LI Qi , ZHAO Wuen . Application and development of high⁃temperature alloys for gas turbines [J]. Journal of Engineering for Thermal Energy &Power , 2004 , 19 （ 5 ）: 447 ⁃ 449 . （in Chinese）

TUCHIDA K , WATHANYU K , SURINPHONG S . Thermal oxidation behavior of TiAlCrSiN and AlCrTiN films on HastelloyX [J]. Advanced Materials Research , 2012 , 486 : 400 ‑ 405 .

WANG Haijun , LUO Yushan , GU Hongfang , et al . Experimental investigation on heat transfer and pressure drop of kerosene at supercritical pressure in square and circular tube with artificial roughness [J]. Experimental Thermal and Fluid Science , 2012 , 42 : 16 ⁃ 24 .

姚燕生，周瑞根，张成林，等 . 增材制造复杂金属构件表面抛光技术 [EB/OL].[ 2021⁃05⁃26 ]. https:∥kns.cnki.net/kcms/detail/11.1929.V.20210524.2051.015.html https://kns.cnki.net/kcms/detail/11.1929.V.20210524.2051.015.html .

GIOVANETTI A J , SZETELAT E J . Long⁃term deposit formation in aviation turbine fuel at elevated temperature [J]. Journal of Propulsion and Power , 1986 , 2 （ 5 ）: 450 ⁃ 456 .

LIU Zhaohui , PAN Hui , FENG Song , et al . Dynamic behaviors of coking process during pyrolysis of China aviation kerosene RP⁃3 [J]. Applied Thermal Engineering , 2015 , 91 : 408 ‑ 416 .

FU Yanchen , WEN Jie , TAO Zhi , et al . Surface coking deposition influences on flow and heat transfer of supercritical hydrocarbon fuel in helical tubes [J]. Experimental Thermal and Fluid Science , 2017 , 85 : 257 ⁃ 265 .

周伟星，韩之雄 . 关键物理因素对RP⁃3航空煤油氧化结焦影响的数值研究 [R]. 福建厦门： 2020年中国工程热物理学会燃烧学年会 , 2020 .

Views

下载量

CSCD

Alert me when the article has been cited

提交

Tools

Publicity Resources

Experiment and numerical calculation on low⁃temperature oxidation characteristics of RP⁃3 aviation kerosene

组合式弹性金属密封泄漏特性实验研究与结构优化

考虑多源不确定性的复合材料风扇叶片高周疲劳失效概率评估

与发动机匹配的旁路式双喉道气动矢量喷管数值模拟研究

基于自适应MOMEDA滚动轴承故障特征提取方法

Related Author

Jing LIU

Erjiang HU

Zuohua HUANG

Wen ZENG

Related Institution

State Key Laboratory of Multiphase Flow in Power Engineering，School of Energy and Power Engineering，Xi'an Jiaotong University

Key Laboratory of Advanced Measurement and Test Technique for Aviation Propulsion System，Liaoning Province，School of Aero⁃engine， Shenyang Aerospace University

AI问答

Postal code：100079
Tel：（010）53879206 Email：tmw@bjxintong.com.cn
Technical support is provided by Beijing Founder electronics co., LTD 京ICP备09082226号-64 京公网安备11010602201714号
It is recommended to read the content of this site in Chrome&IE9+. Please switch to extreme mode in browser 360.
Cookies We use cookies to help provide and enhance our service and tailor content. By continuing, you agree to the use of cookies.

⁰