Flow and heat transfer characteristics of round⁃hole film cooling with crater

Hai WANG; Fangsu FAN; Jian PU; Jianhua WANG; Minghou LIU; Chunhua WANG; Haiying LU

doi:10.13224/j.cnki.jasp.20210174

Chinese

您当前的位置：

首页 >

文章列表页 >

Flow and heat transfer characteristics of round⁃hole film cooling with crater

Combustion,Heat and Mass Transfer | 更新时间：2025-04-07

- Flow and heat transfer characteristics of round⁃hole film cooling with crater
- Journal of Aerospace Power Vol. 37, Issue 3, Pages: 492-501(2022)
- 作者机构：
  
  1.中国科学技术大学热科学和能源工程系，合肥 230027
  2.中国航空发动机集团有限公司沈阳发动机研究所，沈阳 110115
  3.南京航空航天大学能源与动力学院，南京 210016
  4.中国航空发动机集团有限公司中国航空发动机研究院，北京 101304
- 作者简介：
- 基金信息：
- DOI：10.13224/j.cnki.jasp.20210174
  CLC：
- 稿件说明：
移动端阅览
Hai WANG, Fangsu FAN, Jian PU, et al. Flow and heat transfer characteristics of round⁃hole film cooling with crater[J]. Journal of Aerospace Power, 2022, 37(3): 492-501.
DOI：

Hai WANG, Fangsu FAN, Jian PU, et al. Flow and heat transfer characteristics of round⁃hole film cooling with crater[J]. Journal of Aerospace Power, 2022, 37(3): 492-501. DOI： 10.13224/j.cnki.jasp.20210174.

摘要

利用大涡模拟方法对平板带凹坑气膜孔冷气射流与主流的相互作用展开研究，并结合红外热成像壁温测试和粒子图像测速结果进行实验验证，揭示了凹坑对气膜冷却的强化机理。结果表明：凹坑在气膜孔下游诱发反肾型涡对，将冷气向壁面卷吸，改善了气膜贴壁性；与圆孔气膜冷却相似，凹坑气膜冷却流场也出现马蹄涡、发卡涡等大尺度拟序结构，但与圆孔下游的单串列发卡涡不同，凹坑尾缘的“内凹”造型诱发两串并列的发卡涡，且发卡涡结构在大吹风比工况下也较圆孔稳定；脉动信号的频谱分析表明凹坑孔气膜冷却射流周期性弱，流场中低频振荡占主导作用。整体而言，凹坑造型增强了气膜射流的展向扩张，其冷却性能优于圆孔。

Abstract

The interaction between the mainstream and coolant flow from the crater hole on flat plate was studied by large eddy simulation method，and the film⁃cooling enhancement mechanism of crater hole was revealed.The simulation results were compared with the experimental results by infrared thermal imaging test and particle image velocimetry.The results showed that the crater hole generated a pair of anti⁃kidney vortices downstream the coolant exit，promoted the entrainment of coolant towards the wall and improved the coolant coverage.Compared with round hole，large⁃scaled coherent structures including hairpin vortices and horseshoe vortices can also be observed in crater⁃hole flow fields.However，different from round⁃hole，the concave effect on the trailing edge of crater generated parallel lines of hairpin vortices，presenting better stability at high blowing ratio.The time⁃frequency analysis of pressure fluctuation signals showed that the periodicity of crater⁃hole film cooling was weaker，and the small⁃frequency vortices played a dominant role.Overall，crater improved the lateral spreading of coolant jet，and its cooling performance was better than round⁃hole.

关键词

Keywords

references

BUNKER R S . Gas turbine heat transfer:ten remaining hot gas path challenges [J]. Journal of Turbomachinery , 2007 , 129 （ 2 ）: 193 ⁃ 210 .

BUNKER R S . A review of turbine shaped film cooling technology [J]. Journal of Heat Transfer , 2005 , 127 （ 4 ）: 441 ⁃ 453 .

ZHANG Jingzhou , ZHANG Shengchang , WANG Chunhua , et al . Recent advances in film cooling enhancement:a review [J]. Chinese Journal of Aeronautics , 2020 , 33 （ 4 ）: 1119 ⁃ 1136 .

DAVIDSON F T , KISTEMMACHER D A , BOGARD D G . Film cooling with a thermal barrier coating:round holes,craters,and trenches [J]. Journal of Turbomachinery , 2014 , 136 （ 4 ）: 041007.1 ⁃ 041007.11 .

KHALATOV A , SHI⁃JU E , WANG D , et al . Film cooling evaluation of a single array of triangular craters [J]. International Journal of Heat and Mass Transfer , 2020 , 159 : 120055.1 ⁃ 120055.9 .

KALGHATGI P , ACHARYA S . Flow dynamics of a film cooling jet issued from a round hole embedded in contoured crater [J]. Journal of Turbomachinery , 2019 , 141 （ 8 ）: 081006.1 ⁃ 081006.11 .

KIM J H , KIM K Y . Surrogate⁃based optimization of a cratered cylindrical hole to enhance film⁃cooling effectiveness [J]. Journal of Thermal Science and Technology , 2016 , 11 （ 2 ）: 16 ⁃ 208 .

张子寒 , 何坤 , 晏鑫 . 带造型凹坑孔的平板气膜冷却特性研究 [J]. 西安交通大学学报 , 2020 , 54 （ 7 ）: 84 ⁃ 93 .

ZHANG Zihan , HE Kun , YAN Xin . Investigation on the film cooling efficiency on a plain surface with hole embedded in contoured crater [J]. Journal of Xi'an Jiaotong University , 2020 , 54 （ 7 ）: 84 ⁃ 93 . （in Chinese）

张鹏飞 , 白林超 , 张超 . 叶栅环境下凹坑气膜孔的冷却特性研究 [J]. 天津理工大学学报 , 2019 , 35 （ 6 ）: 13 ⁃ 17 .

ZHANG Pengfei , BAI Linchao , ZHANG Chao . Study on film⁃cooling performance of the cratered hole in the linear cascade [J]. Journal of Tianjing University of Technology , 2019 , 35 （ 6 ）: 13 ⁃ 17 . （in Chinese）

SARKAR S , BABU H . Large eddy simulation on the interactions of wake and film⁃cooling near a leading edge [J]. Journal of Turbomachinery , 2015 , 137 （ 1 ）: 011005.1 ⁃ 011005.11 .

ROZATI A , TAFTI D K . Large⁃eddy simulations of leading edge film cooling:analysis of flow structures,effectiveness,and heat transfer coefficient [J]. International Journal of Heat and Fluid Flow , 2008 , 29 （ 1 ）: 1 ⁃ 17 .

TYAGI M , ACHARYA S . Large eddy simulation of film cooling flow from an inclined cylindrical jet [J]. Journal of Turbomachinery , 2003 , 125 （ 4 ）: 734 ⁃ 742 .

SAKAI E , TAKAHASHI T , WATANABE H . Large eddy simulation of an inclined round jet issuing into a crossflow [J]. International Journal of Heat and Mass Transfer , 2014 , 69 : 300 ‑ 311 .

WANG Chunhua , ZHANG Jingzhou , FENG Hongke . Large eddy simulation of film cooling flow from a fan⁃shaped hole [J]. Applied Thermal Engineering , 2018 , 129 : 855 ⁃ 870 .

WANG Chunhua , SUN Xiaokai , FAN Fangsu , et al . Study on trench film cooling on turbine vane by large⁃eddy simulation [J]. Numerical Heat Transfer:Part A Applications , 2020 , 78 （ 7 ）: 338 ⁃ 358 .

吴宏 , 杨庆 . 抑涡孔气膜冷却的大涡模拟 [J]. 航空动力学报 , 2012 , 27 （ 12 ）: 2648 ⁃ 2654 .

WU Hong , YANG Qing . Large eddy simulation of anti⁃vortex film cooling [J]. Journal of Aerospace Power , 2012 , 27 （ 12 ）: 2648 ⁃ 2654 . （in Chinese）

SMAGORINSKY J . General circulation experiments with the primitive equations:Ⅰ the basic experiment [J]. Monthly Weather Review , 1963 , 91 （ 3 ）: 99 ⁃ 164 .

朱兴丹 . 压力梯度主流中圆⁃缝形孔气膜冷却特性研究 [D]. 南京：南京航空航天大学 , 2018 .

ZHU Xingdan . Research on round⁃to⁃slot hole film cooling performances in pressure⁃gradient primary flow [D]. Nanjing : Nanjing University of Aeronautics and Astronautics , 2018 . （in Chinese）

范芳苏 , 王春华 , 冯红科 , 等 . 浅槽孔气膜冷却的大涡模拟研究 [J]. 推进技术 , 2020 , 41 （ 4 ）: 830 ⁃ 838 .

FAN Fangsu , WANG Chunhua , FENG Hongke , et al . Large eddy simulation of film cooling from a shallow trench⁃Hole [J]. Journal of Propulsion Technology , 2020 , 41 （ 4 ）: 830 ⁃ 838 . （in Chinese）

KIM S I , HASSAN I . Unsteady simulations of a film cooling flow from an inclined cylindrical jet [J]. Journal of Thermophysics and Heat Transfer , 2010 , 24 （ 1 ）: 145 ⁃ 156 .

Views

下载量

CSCD

Alert me when the article has been cited

提交

Tools

Publicity Resources

Generation conditions of streamwise vortex in supersonic flat⁃plate boundary layer

Numerical study on effect of film ejections in rotating detonation engine combustor

Effect of inaccurate source term loading on simulation ,precision for source term model

Film cooling enhancement by using upstream sand-dune-shaped ramp

Effects of fully shielded guiding strut on infrared signatures of exhaust system

Related Author

Qian WANG

Zhangfeng HUANG

Yuanshuai WANG

Xiaoming TAN

Jia TIAN

Jingzhou ZHANG

ZHU Jianqin

LI Lin

Related Institution

Department of Mechanics，School of Mechanical Engineering，Tianjin University

苏州科技大学环境科学与工程学院

中国航空工业集团公司中国飞机强度研究所

中国航天科技集团有限公司中国航天空气动力技术研究院空气动力实验与工程应用研究所

唐山学院基础教学部

AI问答

Postal code：100079
Tel：（010）53879206 Email：tmw@bjxintong.com.cn
Technical support is provided by Beijing Founder electronics co., LTD 京ICP备09082226号-64 京公网安备11010602201714号
It is recommended to read the content of this site in Chrome&IE9+. Please switch to extreme mode in browser 360.
Cookies We use cookies to help provide and enhance our service and tailor content. By continuing, you agree to the use of cookies.

⁰