Effect of key parameters on knock of two⁃stroke kerosene engine

Xiaosheng HU; Minxiang WEI; Cheng CHANG; Zhao SHA; Yuzhang DING

doi:10.13224/j.cnki.jasp.20210185

Chinese

您当前的位置：

首页 >

文章列表页 >

Effect of key parameters on knock of two⁃stroke kerosene engine

Combustion,Heat and Mass Transfer | 更新时间：2025-04-07

- Effect of key parameters on knock of two⁃stroke kerosene engine
- Journal of Aerospace Power Vol. 37, Issue 4, Pages: 774-780(2022)
- 作者机构：
  
  南京航空航天大学能源与动力学院，南京 210016
- 作者简介：
- 基金信息：
- DOI：10.13224/j.cnki.jasp.20210185
  CLC：
- 稿件说明：
移动端阅览
Xiaosheng HU, Minxiang WEI, Cheng CHANG, et al. Effect of key parameters on knock of two⁃stroke kerosene engine[J]. Journal of Aerospace Power, 2022, 37(4): 774-780.
DOI：

Xiaosheng HU, Minxiang WEI, Cheng CHANG, et al. Effect of key parameters on knock of two⁃stroke kerosene engine[J]. Journal of Aerospace Power, 2022, 37(4): 774-780. DOI： 10.13224/j.cnki.jasp.20210185.

摘要

针对二冲程汽油发动机改用航空煤油后的爆震抑制和性能恢复进行了研究，利用GT⁃Power软件建立发动机的一维仿真模型并对煤油发动机的爆震进行了预测和优化。仿真结果表明：推迟点火时刻、远低于和远大于理论空燃比的混合气对爆震都有一定的抑制作用，试验结果验证了仿真结果的正确性。提出并采用协同推迟点火和增加喷油的控制策略进行试验研究。试验结果表明：在低转速大负荷工况下，爆震可被有效抑制，节气门全开时功率恢复在90%以上。发动机转速为5 500 r/min时，功率恢复能达到原机的95.7%。

Abstract

Focusing on the performance recovery and knock suppression of two⁃stroke gasoline engine after switching to aviation kerosene，a one⁃dimensional simulation model of kerosene engine was established by GT⁃power，and the knock of kerosene engine was predicted and optimized.The simulation results showed that delaying the ignition time，the mixture far below and far greater than the theoretical air⁃fuel ratio can yield a certain inhibitory effect on knock.The experimental results verified the correctness of the simulation results.The control strategy of collaborative delaying ignition and increasing fuel injection was proposed and used for experimental researches.The results showed that the knock can be effectively suppressed at low speed and heavy load，the power recovery was generally more than 90% when the throttle was fully open.When the engine speed was 5 500 r/min，the power recovery can even reach 95.7% of the original engine.

关键词

Keywords

references

LAWTON J . Development of a heavy fuel engine for an unmanned air vehicle [R]. Orlando,US : the 26th Joint Propulsion Conference ， 1990 .

王兴海，马震，郑勇 . 无人机用小型航空活塞发动机的发展 [C]∥ 中国无人机大会论文集 . 北京：航空工业出版社， 2006 : 523 ⁃ 527 .

BLAIR G P . Design and simulation of two⁃stroke engines [M]. Warrendale，Pennsylvania,US : Society of Automotive Engineers ， 1996 .

MAURICE L ， EDWARDS T ， GRIFFITHS J . Liquid hydrocarbon fuels for hypersonic propulsion [J]. Scramjet Propulsion ， 2001 ， 189 ： 757 ⁃ 822 .

盛敬 . 二冲程煤油发动机爆震燃烧数值模拟与试验研究 [D]. 南京：南京航空航天大学， 2014 .

SHENG Jing . Simulation and experimental study on knock combustion in two⁃stroke kerosene engine [D]. Nanjing : Nanjing University of Aeronautics and Astronautics ， 2014 . （in Chinese）

刘娜，宋玺娟，胡春明，等 . 基于双火花塞点火策略的活塞式航空煤油发动机爆震控制 [J]. 航空动力学报， 2019 ， 34 （ 8 ）: 1671 ⁃ 1676 .

LIU Na ， SONG Xijuan ， HU Chunming ， et al . Knocking control of pistion⁃type aviation kerosene engine based on dual⁃spark plug ignition strategy [J]. Journal of Aerospace Power ， 2019 ， 32 （ 8 ）: 1671 ⁃ 1676 . （in Chinese）

王蕾，赵振峰，俞春存 . 点燃式航空活塞发动机汽油⁃航空煤油燃烧特性 [J]. 航空动力学报， 2020 ， 35 （ 9 ）: 1801 ⁃ 1811 .

WANG Lei ， ZHAO Zhenfeng ， YU Chuncun ， et al . Combustion characteristics of gasoline⁃aviation kerosene in spark ignition aviation piston engine [J]. Journal of Aerospace Power ， 2020 ， 35 （ 9 ）: 1801 ⁃ 1811 . （in Chinese）

SHI Jinshuai ， WANG Yinhui ， LI Xinyan ， et al . Impact of octane number on fuel efficiency of modern vehicles [J]. International Journal of Fuels and Lubricants ， 2013 ， 6 （ 3 ）: 702 ‑ 712 .

SMITH J R ， GREEN R M ， WESTBROOK C K ， et al . An experimental and modeling study of engine knock [J]. Symposium （International） on Combustion ， 1985 ， 20 （ 1 ）: 91 ⁃ 100 .

NATES R J ， YATES A D B . Knock damage mechanisms in spark⁃ignition engines [R]. SAE（Society of Automotive Engineers） Technical Paper 942064 ， 1994 .

SUHY P J ， EVERS L W ， MORGAN E J ， et al . The feasibility of a kerosene fueled spark ignited two⁃stroke engine [R]. SAE（Society of Automotive Engineers） Technical Paper 911846 ， 1991 .

BARAL B ， RAINE R . Knock in a spark ignition engine fuelled with gasoline⁃kerosene blends [R]. SAE（Society of Automotive Engineers） Technical Paper 2008⁃01⁃2417 ， 2008 .

ENOMOTO H ， NOZUE H ， HIEDA N . Effects of EGR on knock⁃level of small spark ignition engine with gasoline⁃base kerosene⁃mixed fuel [R]. SAE（Society of Automotive Engineers） Technical Paper 2013⁃32⁃9114 ， 2013 .

宗培越，胡春明，王书典 . 活塞式航空煤油直喷发动机的爆震控制 [J]. 航空动力学报， 2018 ， 33 （ 3 ）: 635 ⁃ 641 .

ZONG Peiyue ， HU Chunming ， WANG Shudian . Knocking control of direct inject injection piston⁃type aviation kerosene engine [J]. Journal of Aerospace Power ， 2018 ， 33 （ 3 ）: 635 ⁃ 641 . （in Chinese）

陈方超，杨海青，刘锐，等 . 提高四冲程点燃式重油航空发动机抗爆性措施 [J]. 航空动力学报， 2018 ， 33 （ 3 ）: 611 ⁃ 619 .

CHEN Fangchao ， YANG Haiqing ， LIU Rui ， et al . Measures to improve anti⁃knock quality for four⁃stroke ignited kerosene aviation engine [J]. Journal of Aerospace Power ， 2018 ， 33 （ 3 ）: 611 ⁃ 619 . （in Chinese）

刘永长 . 内燃机原理 [M]. 武汉：华中科技大学出版社， 2001 .

GHANAATI A ， SAID M F M ， DARUS I Z M . A comparative study on knock occurrence for different fuel octane number [R]. SAE （Society of Automotive Engineers） Technical Paper 2018⁃01⁃1674 ， 2018 .

LIU Rui ， SHENG Jing ， MA Jie ， et al . Knock combustion investigation on a two⁃stroke spark ignition UAV engine burning RP⁃3 kerosene fuel [J]. Aircraft Engineering and Aerospace Technology ， 2019 ， 91 （ 10 ）: 1278 ⁃ 1284 .

Views

下载量

CSCD

Alert me when the article has been cited

提交

Tools

Publicity Resources

Effect of lean blowout performance of trapped vortex combustor of the afterburner

Research on mixture formation of two⁃stroke heavy fuel direct injection engine

Effect of asynchronous ignition phase on performance of four-stroke engine

Combustion characteristics of gasoline-aviation kerosene in spark ignition aviation piston engine,

Effect of fuel temperature on atomization characteristics of centrifugal nozzle

Related Author

Yunchuan TAN

Huagui ZHONG

Ruili SUN

Haitao SUN

Chuncun YU

Xuefei DONG

Lei WANG

Zhenfeng ZHAO

Related Institution

Sichuan Gas Turbine Establishment，Aero Engine Corporation of China

Energy and Power Technology Research Department，Aerospace Times FeiHong Technology Company Limited

School of Mechanical Engineering，Being Institute of Technology

天津大学机械工程学院

天津大学内燃机研究所

AI问答

Postal code：100079
Tel：（010）53879206 Email：tmw@bjxintong.com.cn
Technical support is provided by Beijing Founder electronics co., LTD 京ICP备09082226号-64 京公网安备11010602201714号
It is recommended to read the content of this site in Chrome&IE9+. Please switch to extreme mode in browser 360.
Cookies We use cookies to help provide and enhance our service and tailor content. By continuing, you agree to the use of cookies.

⁰