导弹从发射箱热发射过程的数值分析

梁晓扬; 苏逸飞; 乐贵高

doi:10.13224/j.cnki.jasp.20210308

Chinese

您当前的位置：

首页 >

文章列表页 >

导弹从发射箱热发射过程的数值分析

火箭发动机 | 更新时间：2025-03-14

- 导弹从发射箱热发射过程的数值分析
- Numerical analysis of hot launch of missile from a launch canister
- 航空动力学报 2022年37卷第8期页码：1643-1653
- 作者机构：
  
  南京理工大学机械工程学院，南京 210094
- 作者简介：
  
  梁晓扬（1989-），男，博士生，研究领域导弹发射过程热力环境。E⁃mail：Mr_Liangxiao@163.com
  乐贵高（1964-），男，教授，博士，主要从事火箭导弹发射系统流体力学数值模拟。E⁃mail：leguigao@njust.edu.cn
- 基金信息：
- DOI：10.13224/j.cnki.jasp.20210308
  中图分类号：
- 稿件说明：
移动端阅览
梁晓扬, 苏逸飞, 乐贵高. 导弹从发射箱热发射过程的数值分析[J]. 航空动力学报, 2022,37(8):1643-1653.

Xiaoyang LIANG, Yifei SU, Guigao LE. Numerical analysis of hot launch of missile from a launch canister[J]. Journal of Aerospace Power, 2022, 37(8): 1643-1653.
梁晓扬, 苏逸飞, 乐贵高. 导弹从发射箱热发射过程的数值分析[J]. 航空动力学报, 2022,37(8):1643-1653. DOI： 10.13224/j.cnki.jasp.20210308.

Xiaoyang LIANG, Yifei SU, Guigao LE. Numerical analysis of hot launch of missile from a launch canister[J]. Journal of Aerospace Power, 2022, 37(8): 1643-1653. DOI： 10.13224/j.cnki.jasp.20210308.

摘要

采用三维可压缩雷诺平均Navier⁃Stokes方程和

k⁃ε

湍流模型，研究了导弹出箱过程中，弹体姿态偏转后弹底周围环境及发射箱内的流场特性。首先，以超声速欠膨胀射流撞击平板实验为算例，对数值方法的有效性进行验证。其次，分别对导弹在约束期和半约束期箱内流动特性展开研究。研究表明：喷管尾流在发射箱内会形成强烈的引射效应。同时，在弹底会出现明显的回流区域，使导弹出箱时受到额外的阻力。考虑偏转后，发射装置受到的冲击载荷增大2倍以上，发射箱壁面受到的压力增加40%。而且，在半约束期，箱内的流场分布不再对称，会使得导弹受到额外的不平衡力矩。

Abstract

Based on the three⁃dimensional compressible Reynolds⁃averaged Navier⁃Stokes equation and the

⁃

turbulence model，the environment around the bottom of the missile and the flow field characteristics in the launch canister after deflection of the missile attitude were investigated.Firstly，the effectiveness of the numerical method was verified by the experiment of supersonic jet impinging on a flat plate.Secondly，the flow characteristics of the launch canister in the constrained and semi⁃confined periods were investigated respectively.The results showed that significant entrainment effect of the exhaust gas can be found in the launch canister.Meanwhile，a backflow area near the bottom of the missile can be observed，which may cause additional drag force on the missile during the launching process.After considering the deflection，the impact load on the launcher was increased by more than two times and the pressure on the launch box wall was increased by 40%.Moreover，the flow field distribution inside the box was no longer symmetrical during the semi⁃confinement period，making the missile subject to additional unbalanced moments.

关键词

Keywords

references

BERTIN J , BERTIN R , YUNG A , et al . The launch⁃tube flow⁃field for a vertical launching system [R]. AIAA 88⁃0332 , 1988 .

SAMIMY M , TURNER W , ADDY A . Backflow induced unsteady aerodynamic forces during tube launch [R]. AIAA 87⁃0464 , 1987 .

BOUSLOG S A , BERTIN J J , WINGERT W B . Flowfield produced by rocket exhaust impingement of a multitube launcher [J]. Journal of Spacecraft and Rockets , 1984 , 21 （ 4 ）: 323 ⁃ 329 .

BERLIN J J , BATSON J L . Experimentally determined rocket⁃exhaust flowfield in a constrictivetube launcher [J]. Journal of Spacecraft and Rockets , 1975 , 12 （ 12 ）: 711 ⁃ 717 .

张程 , 李新田 , 廖选平 , 等 . 固体火箭发动机后效推力对导弹底阻影响的数值仿真 [J]. 航空动力学报 , 2017 , 32 （ 6 ）: 1530 ⁃ 1536 .

ZHANG Cheng , LI Xintian , LIAO Xuanping , et al . Numerical simulation of influences of solid rocket motor post⁃thrust on missile base drag [J]. Journal of Aerospace Power , 2017 , 32 （ 6 ）: 1530 ⁃ 1536 . （in Chinese）

LAMONT P J , HUNT B L . The impingement of underexpanded,axisymmetric jets on perpendicular and inclined flat plates [J]. Journal of Fluid Mechanics , 1980 , 100 （ 3 ）: 471 ⁃ 511 .

NAKAI Y , FUJIMATSU N , FUJII K . Flow classification of the under⁃expanded super sonic jet impinging on a flat plate [R].AIAA 2003 ⁃3467 , 2003 .

NAKAI Y , FUJIMATSU N , FUJII K . Experimental study of underexpanded supersonic jet impingement on an inclined flat plate [J]. AIAA Journal , 2006 , 44 （ 11 ）: 2691 ⁃ 2699 .

BERLIN J J , BATSON J L . Experimentally determined rocket⁃exhaust flowfield in a constrictivetube launcher [J]. Journal of Spacecraft and Rockets , 1975 , 12 （ 12 ）: 711 ⁃ 717 .

SINHA P K , CHAKRABORTY D . Numerical study of hot launch of missile inside a tube [J]. Journal of Aerospace Engineering , 2014 , 228 （ 14 ）: 2604 ⁃ 2611 .

KORST H H , BERTIN J J . Analysis of secondary flows for tube⁃launched rocket configurations [J]. Journal of Spacecraft and Rockets , 1983 , 20 （ 1 ）: 35 ⁃ 42 .

VATSA V N , WEDAN B W . Development of a multigrid code for 3⁃D Navier⁃Stokes equations and its application to a grid⁃refinement study [J]. Computers & Fluids , 1990 , 18 （ 4 ）: 391 ⁃ 403 .

BUSH M B , TANNER R I . Numerical solution of viscous flows using integral equation methods [J]. International Journal for Numerical Methods in Fluids , 1983 , 3 （ 1 ）: 71 ⁃ 92 .

SHIH T H , LIOU W W , SHABBIR A , et al . A new <math id="M56"><mi>k</mi><mi mathvariant="normal">⁃</mi><mi>ϵ</mi></math> http://html.publish.founderss.cn/rc-pub/api/common/picture?pictureId=33779840&type= http://html.publish.founderss.cn/rc-pub/api/common/picture?pictureId=33779836&type= 3.38666677 2.28600001 eddy viscosity model for high reynolds number turbulent flows [J] Computers & Fluids 1995 , 24 （ 3 ）: 227 ‑ 238 .

EL⁃AMIN , M F , SUN S , HEIDEMANN W , et al . Analysis of a turbulent buoyant confined jet modeled using realizable <math id="M57"><mi>k</mi><mi mathvariant="normal">‑</mi><mi mathvariant="normal">ɛ</mi></math> http://html.publish.founderss.cn/rc-pub/api/common/picture?pictureId=33779848&type= http://html.publish.founderss.cn/rc-pub/api/common/picture?pictureId=33779844&type= 3.38666677 2.11666679 model [J]. Heat and Mass Transfer , 2010 , 46 （ 8 ）: 943 ⁃ 960 .

CHIMA R , LIOU M S . Comparison of the AUSM+ and H⁃CUSP schemes for turbomachinery applications [R].AIAA 2003 ⁃4120 , 2003 .

VENKATAKRISHNAN V . Convergence to steady state solutions of the Euler equations on unstructured grids with limiters [J]. Journal of Computational Physics , 1995 , 118 （ 1 ）: 120 ‑ 130 .

ALVI F , IYER K . Mean and unsteady flowfield properties of supersonic impinging jets with lift plates [R]. AIAA 99 ⁃ 1829 ,1999.

浏览量

下载量

CSCD

文章被引用时，请邮件提醒。

提交

工具集

关联资源

带集气腔的脉冲射流冲击换热实验和数值研究

改进的离心压气机滑移因子模型

合成射流控制高速扩压叶栅二次流的数值模拟

固体火箭发动机流体喉部推力矢量特性

液氧甲烷发动机台阶型冷却通道的耦合传热特性