基于神经网络的减阻沟槽壁面形状优化

李超群; 唐硕; 李易; 耿子海

doi:10.13224/j.cnki.jasp.20210683

Chinese

您当前的位置：

首页 >

文章列表页 >

基于神经网络的减阻沟槽壁面形状优化

气动热力学与总体设计 | 更新时间：2025-04-07

- 基于神经网络的减阻沟槽壁面形状优化
- Sub⁃optimization of riblet shape based on neural networks
- 航空动力学报 2022年37卷第3期页码：639-648
- 作者机构：
  
  1.西北工业大学航天学院，西安 710072
  2.西北工业大学航空学院，西安 710072
  3.中国空气动力研究与发展中心低速空气动力研究所，四川绵阳 621000
- 作者简介：
  
  李超群（1995-），男，博士生，主要从事微结构壁面减阻与优化研究。
  李易（1984-），男，副教授，博士，主要从事飞行器设计研究。E⁃mail：dr_liyi@nwpu.edu.cn
- 基金信息：
  
  装备预研
- DOI：10.13224/j.cnki.jasp.20210683
  中图分类号：
- 稿件说明：
移动端阅览
李超群, 唐硕, 李易, 等. 基于神经网络的减阻沟槽壁面形状优化[J]. 航空动力学报, 2022,37(3):639-648.

Chaoqun LI, Shuo TANG, Yi LI, et al. Sub⁃optimization of riblet shape based on neural networks[J]. Journal of Aerospace Power, 2022, 37(3): 639-648.
李超群, 唐硕, 李易, 等. 基于神经网络的减阻沟槽壁面形状优化[J]. 航空动力学报, 2022,37(3):639-648. DOI： 10.13224/j.cnki.jasp.20210683.

Chaoqun LI, Shuo TANG, Yi LI, et al. Sub⁃optimization of riblet shape based on neural networks[J]. Journal of Aerospace Power, 2022, 37(3): 639-648. DOI： 10.13224/j.cnki.jasp.20210683.

摘要

针对沟槽外形减阻问题，采用基于神经网络的方法对沟槽壁面形状进行外形优化。模型采用槽道流动模型，控制方程为黏性不可压缩Navier⁃Stokes（NS）方程，流动求解采用直接数值模拟（DNS）方法，对于对流项的离散采用紧致4阶中心格式，对黏性项的离散采用4阶中心格式，时间推进采用3阶Runge⁃Kutta格式。在神经网络优化过程中，约束方程为不可压NS方程，采用基于在线学习的自适应控制器，使用基于抑制展向切应力的控制律，控制量的产生由壁面变形提供。优化结果表明，壁面最大减阻效果可达17.41%。对于优化后的壁面，湍流强度降低了19.68%，同时壁面的涡量与雷诺切应力亦有所降低。由于湍流流动非定常，因此优化得到的壁面形状亦是时变的，但变化的过程中整体上仍呈现流向沟槽的形状。

Abstract

For the riblet drag reduction，a neural network⁃based method was used to optimize the shape of the riblet surface.This work employed the channel flow model and the governing equations were the viscous incompressible Navier⁃Stokes （NS） equations.The turbulent flow inside the channel was resolved by the direct numerical simulation （DNS） method.According to the numerical method，a compact fourth⁃order central scheme was used for the discretization of the convective term，a fourth⁃order central scheme was applied to the discretization of the viscous term，and a third⁃order Runge⁃Kutta scheme was employed for the time advancement.In the neural network sub⁃optimization process，the constraint equation was the incompressible NS equation，and an adaptive controller based on online learning was used.In the optimization procedure，the control law was based on weakening the spanwise shear stress，and the control quantities were provided by the wall deformation.The optimization results demonstrated that the maximum wall drag reduction reached 17.41%.For the wall optimization，the turbulence intensity was reduced by 19.68%，besides，the vorticity and Reynolds shear stress at the wall also declined.Since the turbulent flow was unsteady，the shape of the optimized wall also varied with time，but the overall shape of the riblets still illustrated a streamwise riblet⁃like configuration.

关键词

Keywords

references

陈迎春 , 张美红 , 张淼 , 等 . 大型客机气动设计综述 [J]. 航空学报 , 2019 , 40 （ 1 ）: 522759.1 ⁃ 522759.7 .

CHEN Yinchun , ZHANG Meihong , ZHANG Miao , et al . Review of large civil aircraft aerodynamic design [J]. Acta Aeronautica et Astronautica Sinica , 2019 , 40 （ 1 ）: 522759.1 ⁃ 522759.7 . （in Chinese）

胡海豹 , 宋保维 , 刘占一，等 . 基于湍流边界层时均速度分布的脊状表面减阻规律研究 [J]. 航空动力学报 , 2009 , 24 （ 5 ）: 1040 ⁃ 1047 .

HU Haibao ， SONG Baowei ， LIU Zhanyi ， et al . Research about the characteristic of drag reduction over riblets surface based on average velocity profile in the turbulent boundary layer [J]. Journal of Aerospace Power , 2009 , 24 （ 5 ）: 1040 ⁃ 1047 . （in Chinese）

WALSH M J . Riblets as a viscous drag reduction technique [J]. AIAA Journal , 1983 , 21 （ 4 ）: 485 ⁃ 486 .

WALSH M J . Effect of detailed surface geometry on riblet drag reduction performance [J]. Journal of Aircraft , 1990 , 27 （ 6 ）: 572 ⁃ 573 .

LUCHINI P , MANZO F , POZZI A . Resistance of a grooved surface to parallel flow and cross⁃flow [J]. Journal of Fluid Mechanics , 1991 , 228 : 87 ⁃ 109 .

常跃峰 , 姜楠 . 沟槽壁湍流多尺度相干结构实验研究 [J]. 航空动力学报 , 2008 , 23 （ 5 ）: 788 ⁃ 795 .

CHANG Yuefeng , JIANG Nan . Experimental study on coherent structure passive control and drag reduction in turbulent boundary layer with grooved surface [J]. Journal of Aerospace Power , 2008 , 23 （ 5 ）: 788 ⁃ 795 . （in Chinese）

王晋军 , 陈光 . 沟槽面湍流边界层近壁区拟序结构实验研究 [J]. 航空学报 , 2001 , 22 （ 5 ）: 400 ⁃ 405 .

WANG Jinjun , CHEN Guang . Experimental studies on the near wall turbulent coherent structures over riblets surfaces [J]. Acta Aeronautica et Astronautica Sinica , 2001 , 22 （ 5 ）: 400 ⁃ 405 . （in Chinese）

CUI G Y , PAN C , WU D , et al . Effect of drag reducing riblet surface on coherent structure in turbulent boundary layer [J]. Chinese Journal of Aeronautics , 2019 , 32 （ 11 ）: 2433 ⁃ 2442 .

王二丹，田海平，张静娴，等 . 超疏水壁面湍流边界层减阻机理的TRPIV实验 [J]. 航空动力学报 , 2016 , 31 （ 12 ）: 2870 ⁃ 2877 .

WANG Erdan , TIAN Haiping , ZHANG Jingxian , et al . TRPIV experimental investigation of drag⁃reduction mechanism in turbulent boundary layer over super hydrophobic surfaces [J]. Journal of Aerospace Power , 2016 , 31 （ 12 ）: 2870 ⁃ 2877 . （in Chinese）

SUNDARAM S , VISWANATH P R , RUDRAKUMAR S . Viscous drag reduction using riblets on a NACA 0012 airfoil to moderate incidence [J]. AIAA Journal , 1996 , 34 （ 4 ）: 676 ‑ 682 .

SUBASHCHANDAR N , RAJEEV K , SUNDARAM S . Drag reduction due to riblets on a GAW（2） airfoil [J]. Jornal of Aircraft , 1999 , 36 （ 5 ）: 890 ⁃ 892 .

ZHANG Y F , CHEN H X , FU S , et al . Numerical study of an airfoil with riblets installed based on large eddy simulation [J]. Aerospace Since and Technology , 2018 , 78 : 661 ⁃ 670 .

张子良 , 张明明 . 仿生减阻翼型的气动性能 [J]. 航空动力学报 , 2021 , 36 （ 8 ）: 1740 ⁃ 1748 .

ZHANG Ziliang , ZHANG Mingming . Aerodynamic performance for bionic drag⁃reducing airfoil [J]. Journal of Aerospace Power , 2021 , 36 （ 8 ）: 1740 ⁃ 1748 . （in Chinese）

JIMÉNEZ J , MOIN P . The minimal flow unit in near⁃wall turbulence [J]. Journal of Fluid Mechanics , 1991 , 225 : 213 ⁃ 240 .

CARLSON H , LUMLEY J . Active control in the turbulent wall layer of a minimal flow unit [J]. Journal of Fluid Mechanics , 1996 , 329 : 341 ⁃ 371 .

KIM J , MOIN P . Application of a fractional⁃step method to incompressible Navier⁃Stokes equations [J]. Journal of Computational Physics , 1985 , 59 （ 2 ）: 308 ⁃ 323 .

CHOI H , MOIN P , KIM J . Direct numerical simulation of turbulent over riblets [J]. Journal of Fluid Mechanics , 1993 , 255 : 503 ⁃ 539 .

CHU C D , KARNIADAKIS E G . A direct numerical simulation of laminar and turbulent flow over riblet⁃mounted surfaces [J]. Journal of Fluid Mechanics , 1993 , 250 : 1 ⁃ 42 .

GOLDSTEIN D , HANDLER R , SIROVICH L . Direct numerical simulation of turbulent flow over a modeled riblet covered surface [J]. Journal of Fluid Mechanics , 1995 , 302 : 333 ⁃ 376 .

CHOI H , MOIN P , KIM J . Active turbulence control for drag reduction in wall⁃bounded flows [J]. Journal of Fluid Mechanics , 1994 , 262 : 75 ⁃ 110 .

ENDO T , KASAGI N , SUZUKI Y . Feedback control of wall turbulence with wall deformation [J]. International Journal of Heat and Fluid Flow , 2000 , 21 （ 5 ）: 568 ⁃ 575 .

KANG S , CHOI H . Active wall motions for skin⁃friction drag reduction [J]. Physics of Fluids , 2000 , 12 （ 12 ）: 3301 ⁃ 3304 .

LEE C , KIM J , BABCOCK D , et al . Application of neural networks to turbulence control for drag reduction [J]. Physics of Fluids , 1997 , 9 （ 6 ）: 1740 ⁃ 1747 .

HAN Bingzheng , HUANG Weixi . Active control for drag reduction of turbulent channel flow based on convolutional neural networks [J]. Physics of Fluids , 2020 , 32 （ 9 ）: 095108.1 ⁃ 095108.13 .

RABAULT J , KUCHTA M , JENSEN A , et al . Artificial neural networks trained through deep reinforcement learning discover control strategies for active flow control [J]. Journal of Fluid Mechanics , 2019 , 865 : 281 ⁃ 302 .

VIQUERAT J , RABAULT J , KUHNLE A , et al . Direct shape optimization through deep reinforcement learning [J]. Journal of Computational Physics , 2021 , 428 : 110080.1 ⁃ 110080.12 .

LELE S K . Compact finite difference schemes with spectral⁃like resolution [J]. Journal of Computational Physics , 1992 , 103 （ 1 ）: 16 ⁃ 42 .

SHAH A , FAYYAZ H , RIZWAN M . Fourth⁃order central compact scheme for the numerical solution of incompressible Navier⁃Stokes equations [J]. International Journal of Computer Mathematics , 2017 , 94 （ 12 ）: 2492 ⁃ 2507 .

LORANG LV , PODVIN B , Le QUÉRÉ P . Application of compact neural network for drag reduction in a turbulent channel flow at low Reynolds numbers [J]. Physics of Fluids , 2008 , 20 （ 4 ）: 045104.1 ⁃ 045104.13 .

POPE S B . Turbulent flows [M]. Cambridge : Cambridge University Press , 2000 .

浏览量

下载量

CSCD

文章被引用时，请邮件提醒。

提交

工具集

关联资源

掠型设计调控跨声速离心压气机内部流动机理

短舱外侧导流片对民用运输机低速特性影响

脉冲射流控制现象的自激⁃外激耦合模型

横向矩形微槽对高超边界层失稳的控制作用

放电电阻对等离子合成射流激励器特性的影响